Briggs & Stratton 5900619 manual Lubrication, Grease Oil

Page 34

Regular Maintenance

LUBRICATION

Lubricate the unit at the locations shown in Figure 20 through 24.

Grease:

Oil:

Use grease fittings when present. Disassemble parts to apply grease to moving parts when grease fittings are not installed.

Not all greases are compatible. Ferris Red Grease (P/N 5022285) is recommended, automotive-type high-temperature, lithium grease may be used when this is not available.

Generally, all moving metal parts should be oiled where contact is made with other parts. Keep oil and grease off belts and pulleys. Remember to wipe fittings and surfaces clean both before and after lubrication.

Maintenance

Figure 20. Deck Lift Linkage Pivots

Figure 21. Deck Lubrication

RE-PACK

BEARINGS

ANUALLY

Figure 23. Control Handle Pivots & Seat Pivots

Figure 24. Gearbox Drive Idler Pivot

Figure 22. Front Caster & Wheel

 

32

www.ferrisindustries.com

Page 33 Page 35
Image 34
Page 33 Page 35
Contents
Manual Date Purchased Table of Contents Operating Safety Slope Operation Roll Bar Use Fuel and Maintenance Operation Slope Operation Service and Maintenance Roll BAR Instructions Inspection and Maintenance of the Roll BAR Seat Belt CE Identification TAG Markings Safety Decals Safety DecalsNorth American Models CE Models Export Safety Icons Safety Interlock System Safety Interlock SystemOperational Safety Checks Ignition Switch Features & ControlsSeat Adjustment Lever Ground Speed LeversHour Meter / Maintenance Reminder PTO Power Take Off SwitchGlow Plug Indicator Oil Pressure IndicatorOperation General Operating SafetyChecks Before Starting On the water separator Priming the Fuel SystemTo prime the fuel system On the engine fuel filterStopping the Tractor & Engine Starting the EngineDriving the Tractor Pushing the Rider by Hand Do not TOW RiderForward Travel Practice Zero Turn Driving PracticeSmooth Travel Reverse Travel PracticeExecuting an End-Of-Row Zero Turn Practice Turning Around a CornerPractice Turning In Place Executing TurnsHeight of Grass MowingMowing Recommendations Tall Grass Requires Incremental CuttingMowing Patterns When and How Often to MowMowing Methods Proper Broadcast MowingAttaching a Trailer Proper MulchingTo raise the roll bar Raise & Lower the Roll BARTo lower the roll bar Keep roll bar in the raised position and use seat beltDiesel Fuel Recommendations StorageStarting After Long Term Storage Temporary Storage 30 Days Or Less Check Tire Pressures Regular Maintenance Maintenance Schedule & Procedures Before Every Spring Each 100 250 Fall Use HoursFuel Filter Checking / Adding FuelTo add fuel Hydraulic OIL Filter Change Check / ADD Engine OILCheck / Change AIR Filter Check Hydraulic OIL Level Change Interval Every 500 Hours Filter Part NumberRadiator Pressure Cap Change Engine Coolant Clean RADIATOR, Screen & OIL CoolerCheck Engine Coolant Level Radiator ScreenLubrication Grease OilCleaning the Battery and Cables Battery MaintenanceANTI-SCALP Deck Casters Servicing the Mower Blades Removing the BladeTroubleshooting Warning Troubleshooting, Adjustments & ServiceTroubleshooting the Rider Rider Troubleshooting Troubleshooting, Adjustment & ServiceTroubleshooting the Mower Troubleshooting Common Cutting Problems StreakingGround Speed Lever Adjustment Seat AdjustmentSpeed Balancing Adjustment Neutral Position Adjustment Neutral AdjustmentNeutral Position and Return Spring Adjustment Return Spring Adjustment1/8 Parking Brake Adjustment5,4cm To discover how many shims are needed Rear Tire Camber AdjustmentInstalling the camber shims Distance Measured Number of ShimsUse two hands when adjusting the shock Suspension AdjustmentTo adjust the spring pre-load Springs. This will prevent the wrench fromMowing Height Adjustment Inner Rod Deck Lift ROD Timing AdjustmentOuter Rod Deck Leveling Adjustment Deck Lift SpringMower Drive Belt Removal Replacement Belt Removal & ReplacementSide Discharge Model Models Rear Discharge Models Clutch Belt Replacement Clutch Belt RemovalPump Drive Belt Replacement Pump Drive Belt RemovalChanging Gearbox Oil Gearbox MaintenanceCheck Gearbox Oil Level FrontBattery Service Checking Battery VoltageTroubleshooting, Adjustment & Service Jump StartingEngine SpecificationsDimensions ChassisFerris Limited Warranty OPERATOR’S Manual
Top Page Image Contents