Exmark Lawn Tractor manual

Page 14

PART NO. 103-3997 LOCATION: RH Side of Console

PART NO. 1-403005

LOCATION: Left and Right Corners

of Mower Deck

PART NO. 103-6319

LOCATION: Bottom Side of Floor Pan

PART NO. 1-303508

LOCATION: RH Side on Top Rear of Mower Deck

PART NO. 1-633313

LOCATION: RH Side on Top

Front of Mower Deck

PART NO. 1-513748

LOCATION: Bottom Side

of Floorpan

PART NO. 1-523552

LOCATION: Top of Hydraulic

Reservoir, Under

the Seat

PART NO. 1-633462

LOCATION: Rubber Heat Shield

Flap behind Seat

PART NO. 1-513742

LOCATION: Top of Mower Deck Belt

Shields, Left and Right

Sides

PART NO. 107-2102

LOCATION: Inside Surface of

Upper Roll bar

- 9 -

Image 14

Contents For Serial Nos 540,000 & Higher Potential Hazard Exmark Parts PLUS→ Program Operators Manual Table of Contents Preparation Safety Alert SymbolTraining Carbon monoxide can kill you Potential Hazard Operation Safe Zone for Mowing There is no rollover protection when the roll bar is down Maintenance and Storage Safety Signs Page Page Fuel System Specifications Model NumberEngine Electrical SystemCutting Deck Hydrostatic Ground Drive SystemTires Torque Requirements DimensionsUncrate Mower Install Rollover Protection System Roll BAR Lower Roll BAR Installation Machine is shipped with a filled lead acid battery Service BatteryUpper Roll BAR Installation Charging the battery may produce explosive gasses Install Motion Control Levers Install Drive WheelsInstall Seat Check Tire PressureControls Service Engine Service Hydraulic OILPosition Discharge Chute Motion Control PositionsPush the lever forward and down to disengage the brake PRE-START Operating InstructionsStarting Engine Transporting Periodic Maintenance Service Interval DailyService Interval Monthly Service Interval Daily or more often in dry conditionsService Interval Daily Blade Bolt Installation Service Interval 100 hrs Service Interval Refer to chart Service Interval 40 hrService Interval 40 hrs Caster Wheel Assembly Lubrication ChartService Interval Once Yearly Service Interval 160 hrs Service Interval 80 hrsService Interval 500 hrs Service Interval As RequiredService Interval After First 250 hrs Then yearly thereafter Adjustments Cutting Height PositionANTI-SCALP Roller Adjustment Swivel Adjustment Spring Compression Adjustment Self-tensioning No adjustment necessaryMule Drive Belt Adjustment Belt Guide PositioningThrottle Tension Brake AdjustmentNo adjustment necessary Reverse Indicator Adjustment Motion Control Adjustment Armrest Adjustment Battery DisposalCaster Adjustment Motor OIL DisposalMower Cuts Unevenly Engine will not StartEngine Troubleshooting Table ProblemElectrical Diagram Hydraulic Diagram Year Limited Warranty Service Record Page See EXMARK’S Complete Line of Accessories