Exmark Lawn Tractor manual

Page 15

	PART NO. 103-0262
	LOCATION: Center Front of	PART NO. 1-643222
	Console
		LOCATION: Left of Center on Mower
	PART NO. 1-633922
		Deck, Under Floor Pan
	LOCATION: Front Center on Top of Mower Deck

PART NO. 103-0368

LOCATION: Rubber Heat Shield Flap behind SeatPART NO. 1-643339

LOCATION: Top of Right Engine Baffle

PART NO. 103-7491

LOCATION: LH Side on Top Front of Mower Deck

PART NO. 103-3270 LOCATION: On Engine

	PART NO. 98-5954
	LOCATION: Under Mower Deck
PART NO. 107-2112	Belt Shield(s)
PART NO. 107-2112	PART NO. 103-5368
LOCATION: Top Center of Floorpan	LOCATION: LH Side of Cutting
	Height Adjustment Plate

PART NO. 103-9256

LOCATION: Top of console

- 10 -

Image 15

Contents For Serial Nos 540,000 & Higher Potential Hazard Exmark Parts PLUS→ Program Operators Manual Table of Contents Safety Alert Symbol TrainingPreparation Carbon monoxide can kill you Potential Hazard Operation Safe Zone for Mowing There is no rollover protection when the roll bar is down Maintenance and Storage Safety Signs Page Page Electrical System Specifications Model NumberEngine Fuel SystemHydrostatic Ground Drive System TiresCutting Deck Dimensions Uncrate Mower Install Rollover Protection System Roll BARTorque Requirements Lower Roll BAR Installation Service Battery Upper Roll BAR InstallationMachine is shipped with a filled lead acid battery Charging the battery may produce explosive gasses Check Tire Pressure Install Drive WheelsInstall Seat Install Motion Control LeversMotion Control Positions Service Engine Service Hydraulic OILPosition Discharge Chute ControlsPush the lever forward and down to disengage the brake Operating Instructions PRE-STARTStarting Engine Transporting Service Interval Daily Periodic MaintenanceService Interval Daily or more often in dry conditions Service Interval MonthlyService Interval Daily Blade Bolt Installation Service Interval 100 hrs Service Interval 40 hr Service Interval 40 hrsService Interval Refer to chart Lubrication Chart Service Interval Once YearlyCaster Wheel Assembly Service Interval 80 hrs Service Interval 160 hrsService Interval As Required Service Interval After First 250 hrs Then yearly thereafterService Interval 500 hrs Cutting Height Position AdjustmentsANTI-SCALP Roller Adjustment Self-tensioning No adjustment necessary Swivel Adjustment Spring Compression AdjustmentBelt Guide Positioning Mule Drive Belt AdjustmentBrake Adjustment No adjustment necessaryThrottle Tension Reverse Indicator Adjustment Motion Control Adjustment Motor OIL Disposal Battery DisposalCaster Adjustment Armrest AdjustmentEngine will not Start Mower Cuts UnevenlyProblem Engine Troubleshooting TableElectrical Diagram Hydraulic Diagram Year Limited Warranty Service Record Page See EXMARK’S Complete Line of Accessories