Ferris Industries 5900605, IS1500Z, 5900607, 5900606 Servicing the Mower Blades, Removing the Blade

Page 31

SERVICING THE MOWER BLADES

1.Blades should be sharp and free of nicks and dents. If not, sharpen blades as described in the following steps.

2.To remove blade for sharpening, use a 1” wrench on the flats of the spindle shaft while removing the blade mounting bolt with a 15/16” wrench (Figure 22).

3.Use a file to sharpen blade to fine edge. Remove all nicks and dents in blade edge. If blade is severely damaged, it should be replaced.

4.Balance the blade as shown in Figure 23. Center the blade’s hole on a nail lubricated with a drop of oil. A balanced blade will remain level.

5.Reinstall each blade with the tabs pointing up toward deck as shown in Figure 24. Secure with a bolt and flat washer and torque bolts to 70 ft.lbs. (94 N.m.).

WARNING

Mower blades are sharp. For your personal safety, do not handle mower blades with bare hands. Careless or improper handling of blades may result in serious injury. For your personal safety, blade mounting bolts must each be installed with a flat washer then securely tightened. Torque blade mounting bolts to 70 ft.lbs. (94 N.m.)

Regular Maintenance

Figure 22. Removing the Blade

Nail

Figure 23. Balancing The Blade

Maintenance

Figure 24. Installing The Blade

A.Blade Bolt

B.Flat Washer

29

Image 31
Contents Model Number DescriptionFerris Industries Date Purchased Table of Contents Safety Rules & Information Operating SafetySlope Operation Roll Bar Use Fuel and Maintenance Training OperationPreparation Emissions Slope OperationTowed Equipment RIDE-ON Units ChildrenMaintenance and Storage Service and MaintenanceSafe Handling of Gasoline Operational Warnings Roll BAR InstructionsInspection and Maintenance of the Roll BAR Seat Belt Identification Identification NumbersSafety Decals Safety DecalsNorth American Safety Icons Safety Interlock SystemOperational Safety Checks Control Functions Features & ControlsSeat Adjustment Lever Ignition SwitchThrottle Control PTO Power Take Off SwitchHour Meter / Maintenance Reminder Parking BrakeOperation General Operating SafetyChecks Before Starting Stopping the Rider Starting the EnginePushing the Rider by Hand Reverse Travel Practice Zero Turn Driving PracticeSmooth Travel Forward Travel PracticeExecuting an End-Of-Row Zero Turn Practice Turning Around a Corner Practice Turning In PlaceTall Grass Requires Incremental Cutting MowingMowing Recommendations Height of GrassProper Broadcast Mowing When and How Often to MowMowing Methods Mowing PatternsProper Mulching Attaching a TrailerKeep roll bar in the raised position and use seat belt Raise & Lower the Roll BARTo lower the roll bar To raise the roll barLong Term Storage Longer Than 30 Days StorageStarting After Long Term Storage Temporary Storage 30 Days Or LessCheck Tire Pressures Safety ItemsRider Maintenance Engine MaintenanceFuel Filter Regular MaintenanceEngine Maintenance Checking / Adding FuelGrease LubricationOil Change Hydraulic OIL Filter Battery MaintenanceCleaning the Battery and Cables Check Hydraulic OIL LevelRemoving the Blade Servicing the Mower BladesTroubleshooting the Rider TroubleshootingTroubleshooting the Mower Troubleshooting, Adjustment & ServiceTroubleshooting Common Cutting Problems Troubleshooting, Adjustment & ServiceGround Speed Control Lever Adjustment Seat AdjustmentSpeed Balancing Adjustment Parking Brake Adjustment Brake Spring Adjustment Nut Parking Brake AdjustmentTo adjust the spring pre-load Rear Suspension AdjustmentTo adjust the upper mounting position Blade Brake Check PTO Clutch AdjustmentNeutral Adjustment RETURN-TO-NEUTRAL AdjustmentFoot Pedal Adjustment Mowing Height AdjustmentTo adjust pedal position Check Lift Rod Timing Deck Leveling AdjustmentHydraulic Pump Drive Belt Replacement Mower PTO Belt Idler Arm Stationary Idler Pulley Mower Belt ReplacementJump Starting With Auxiliary Booster Battery Battery ServiceChecking Battery Voltage Charging a Completely Discharged BatteryMake Certain Vehicles do not Touch This HOOK-UP for Negative Ground VehiclesChassis SpecificationsDimensions EngineFerris Limited Warranty Tractor Belts and BladesMower Deck