CHECK WHEEL DRIVE CONTROL (self-propelled models)

The unit must stop quickly and completely when the control is released. Adjust or repair if necessary. See Service and Adjustments.

CHECK GRASS BAG

Check grass bag frequently for wear or deterioration. Replace worn or damaged bag with Ariens original equipment replacement bag only.

CLEAN UNIT

Before each use clean unit, muffler and engine surfaces of debris, oil or fuel spills to ensure proper cooling and prevent fires.

CHECK ENGINE OIL

IMPORTANT: Proper oil level must be maintained at all times or engine damage will result.

Check the level of the engine crankcase oil before each use.

Make sure engine is level when checking oil. See engine manual for instructions.

CHECK MOWER BLADE

See Figure 7.

Check blade mounting: blade must be secure and bolt torqued to 37.5 - 50 ft. lbs. (bolt should fully compress lock washer).

Check blade for nicks and dull cutting edges. Sharpen if necessary.

Check blade for rounded or broken ends, thinned metal or other damage. Replace if necessary.

NOTE: Blades should be sharpened and balanced professionally. Contact your Ariens Dealer.

To remove blade:1.Block blade to prevent rotation.2.Remove bolt, lock washer, flat washer and blade from shaft.To install blade:1.Replace blade, flat washer, lock washer and bolt on shaft.

2.Torque bolt to 37.5 - 50 ft. lbs. (bolt should fully compress lock washer).

32

1

1

OM0235

Replace

4

OM0246

1.Cutting Edge2.Square Corner3.Air Lift4.Air Lift Erosion Figure 7

CHECK DRIVE BELT

Check drive belt and replace if worn ordamaged. See Service and Adjustments.

CHECK FASTENERS

Check all fasteners for proper tightness. Pay special attention to blade hardware and all guards, shields and safety devices.

CHECK AIR CLEANER

See engine manual for specific information.

CHANGE ENGINE OIL

IMPORTANT: Change engine crankcase oil after first five (5) hours of operation. Then change oil after every 25 hours of operation.

Refer to engine manual for instructions and proper oil type.

IMPORTANT: Proper oil level must be maintained at all times or engine damage will result. DO NOT overfill. Be sure engine is level when adding oil.

GENERAL LUBRICATION

Mower
Mower requires no lubrication.

CHECK SPARK PLUG

Spark plug should be replaced every 100 hours of operation or each year.

GB - 14