Appendix C
Premier OHV Series
Information in this Appendix applies to the following Baldor Generators:
OHV30, OHV50, OHV60, OHV60E, OHV85E
Caution: The brass connecting tab on some 120VAC duplex receptacles have been removed. Each receptacle is powered by a separate generator winding. When replacing a receptacle, inspect the brass tab that normally links both receptacles. If it is removed, be sure to remove the brass tab from the replacement receptacle before it is installed. Failure to remove the tab will cause a direct short to the generator windings and cause possible generator damage.
Operator Panel Configuration
120 VOLTS | 120 VOLTS |
ELAPSED | AC CIRCUIT BREAKER |
| |
TIME |
|
Figure C-1 OHV30 Operator Panel
NEMA 5-20R GFCI Receptacle.
This ground fault circuit interrupter duplex receptacle is rated at 125VAC, 20 Amps.
Standard Duplex Receptacle. Standard household receptacle rated for 125VAC, 30 Amp When using this receptacle, ground fault protection is provided by the GFCI receptacle.
Hour Meter.
Displays the total run time hours of the generator set.
Circuit Breaker.
Provide overload protection for the generator set.
Figure C-2 OHV40/OHV50/OHV60/OHV60E Operator Panel
| CIRCUIT | ELAPSED | CIRCUIT | |
|
| TIME | ||
| BREAKER |
| BREAKER | |
|
|
| ||
|
|
| AC |
|
|
| VOLTMETER |
| |
15 AMPS | 30AMPS |
|
| 15 AMPS 30AMPS |
120 VOLTS | 120 VOLTS | AUTO IDLER | 120VOLTS 120/240VOLTS | |
|
|
| ||
|
| ON | OFF |
|
Circuit Breaker.
Provide overload protection for the generator set.
120 Volts NEMA
This ground fault circuit interrupter duplex receptacle is rated at 125VAC, 20 Amps.
120 Volts NEMA
120/240 Volts NEMA
AC Voltmeter. This voltmeter displays the voltage level being produced by the generator set. Elapsed Time. Displays the total run time hours of the generator set.
Auto Idler Switch. ON - Auto idler is active, engine RPM will reduce when load is removed. OFF - Engine runs at fixed speed (set by governor).
Figure C-3 OHV85E Operator Panel
AUTO IDLER
ON 
DC
ELAPSED
TIME
AC
VOLTMETER
AC CIRCUIT
BREAKERS
120 VOLTS
120 VOLTS
120/240 VOLTS
120 VOLTS
Auto Idler Switch.
ON - Auto idler is active, engine RPM will reduce when load is removed. OFF - Engine runs at fixed speed (set by governor).
DC ON - Auto Idler is Off and DC output terminals have power for 12V loads.
Elapsed Time.
Displays the total run time hours of the generator set.
AC Voltmeter.
This voltmeter displays the voltage level being produced by the generator set.
AC Circuit Breakers.
Provide overload protection for the generator set.
120 Volts NEMA
This ground fault circuit interrupter duplex receptacle is rated at 125VAC, 15 Amps.
120 Volts NEMA
120/240 Volts NEMA
MN2410 | Premier OHV Series |
