Ignitor Lighting

sDo not lean over grill while lighting.

1.Turn OFF gas burner control valves.

2.Turn ON gas source or tank.

3.Open lid during lighting.

4. To ignite, turn ignition left knob to PRE-HEAT ,Go to step 3 .

5.Push IGNITOR button rapidly.

6.If ignition doe NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.

7.To ignite right burner, turn right knob to PRE-HEAT.

If ignitor does not work, follow match lighting instructions.

CAUTION

If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.

Match-Lighting

sDo not lean over grill while lighting.

1.Open lid during lighting. Turn on gas at LP tank.

2.Place lit match into match holder, then into side of grill bottom (as shown below).

3.Push in and turn IGNITION BURNER knob to HI. Be sure burner lights and stays lit.

4.To ignite right burner, turn right knob to HI.

Burner Flame Check

•Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LO. You should see a smaller flame in LO position than seen on HI. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

HI

LO

Turning Grill Off

•Turn all knobs to OFF position. Turn LP tank off by turning hand-wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP tank. Press ignitor button rapidly. "Click" should be heard and spark seen each time between collector box or burner and electrode. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP tank before checking valves. Knobs lock in OFF position. To check valves, first push in knobs and release, knobs should spring back. If knobs do not spring back, replace valve assembly before using grill. Turn knobs to LO position then turn back to OFF position. Valves should turn smoothly.

Hose Check

•Before each use, check to see if hoses are cut or worn. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer.

General Grill Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry.

useDo not citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Porcelain surfaces: Because of glass-like composition, most residue can be wiped away with baking soda/water solution or specially formulated cleaner. Use nonabrasive scouring powder for stubborn stains.

•Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth.

•Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

8 • 463821908

Page 7 Page 9
Page 8
Image 8
Char-Broil 463821908 manual Ignitor Lighting, Burner Flame Check, Turning Grill Off, Ignitor Check, Valve Check, Hose Check
Page 7 Page 9

463821908 specifications

The Char-Broil 463821908 is a highly regarded gas grill that offers exceptional performance and versatility for outdoor cooking enthusiasts. With a sleek design and user-friendly features, this grill is perfect for backyard barbecues or family gatherings.

One of the standout features of the Char-Broil 463821908 is its four stainless steel burners, which deliver a total of 36,000 BTUs of cooking power across the main grilling area. This allows for ample cooking space, making it easy to prepare meals for larger groups. The grill also includes a side burner, providing an additional 10,000 BTUs, perfect for simmering sauces or preparing side dishes while grilling.

The cooking surface features a generous 480 square inches of primary grilling space, complemented by a warming rack that adds another 180 square inches. This combination allows for efficient meal preparation, giving users the ability to cook multiple items simultaneously without compromising on quality.

Durability is a key characteristic of the Char-Broil 463821908, as it is constructed with a combination of stainless steel and durable porcelain-coated grates, contributing to its longevity and ease of maintenance. The porcelain-coated cast iron grates allow for excellent heat retention and distribution, ensuring evenly cooked food with those classic grill marks.

Char-Broil's innovative TRU-Infrared cooking technology is another defining feature of this grill. This technology helps to eliminate flare-ups and provides even heat distribution, resulting in juicier steaks and perfectly cooked burgers. TRU-Infrared cooking also enhances fuel efficiency, allowing users to accomplish more with less propane, maximizing grilling time.

In terms of convenience, the Char-Broil 463821908 includes an easy-to-read lid-mounted temperature gauge, ensuring precise cooking control. The grill is also equipped with a quick start electronic ignition system, allowing for effortless startups. Further enhancing usability, the grill features side shelves for added workspace, perfect for prep and serving.

For those seeking a reliable, efficient, and user-friendly gas grill, the Char-Broil 463821908 stands out with its combination of features, durability, and innovative technologies, making it an excellent choice for grilling aficionados. Whether you are a seasoned griller or just starting, this model is designed to deliver an unparalleled cooking experience.
Top Page Image Contents