21, Mower Removal
a, Remove mower belt per instructionsunder"Mower
Drive Belt Removal"through step (c).
b_ Remove retainer springfrom clutchrod; pullclutch rod out of clutch bracket. (Fig°29)
co Putt retainer springs out of rear suspension trun- nionsoRemove rear suspensiontrunnionsfrom lift brackels (Fig 29).
do Pull retainer spring out of rear hinge pin, Remove rear hinge pin°(F_., 29)°
e.Pull retainer spring out of front hinge pin.,Remove fronthinge pin (Fig. 29).
f, Use lift leverto raise suspension arms. Slide mower out from under tractor,
NOTE: tFAN ATTACHMENT OTHER THAN THE MOWER DECK tS TO BE MOL.INTED ON THE TRACTOR, THE LH AND R.Ho SUSPENSION ARMS (FIG.
29)SHOULD BE REMOVED FROM TRACTOR.
22, Mower Installation
Your Mower installswithout the use of tools. Raise attach- ment lift lever (Fig, 30) to itshighest position.
a, Slide mower under tractor,dischargeguard to R H, side,.
b, Install front hinge pin through axle and parallel link (Fig. 32)., Secure with retainer spring,
c, install rear hinge pin through mower lift brackets and parallel link (Fig. 32) Secure with retainer spring..
d, Install clutch rod in clutch lever (Fig. 32).
e.Move attachment liftlever (Fig.,30) forwardto lower suspension arms, Slide trunnions through lift bracket holes and secure with retainer springs(Fig. 29)°
fo Roll belt over engine pulley.,Make sure belt isinside belt guides (Fig 32). See belt driveschematicdecal on mower housing
g_ Use attachment lift lever (Fig. 30) to raise mower,
h Push lift lever plunger down and position attachment lift lever to desired cutting height (Fig. 31). Release lift lever plunger
RETAINERR.H.
SPRINGSUSPENTION
ARM
REPAIR AND ADJUSTMENT
ATTACHMENT | LIFT LEVER | i LIFT LEVER |
CLUTCH LEVER | PLUNGER | "HIGHEST" |
"DISENGAGED" |
| POSITION |
POSITION |
|
|
|
| LIFT LEVER |
|
| "LOWEST" |
|
| ,POSITION |
FIGURE 30
0
00
FIGURE 31
RETAINERENGINE RETAINER
SPRINGPULLEY SPRINGS
CLUTCH
RODBELTFRONT
CLUTCH ROD
\
RETAINER SPRINGS
GUIDESAXLE
|
|
| / |
|
| 7 |
|
|
|
|
|
| |
REAR / |
|
|
|
|
| FRONT |
|
|
|
| REAR | HINGE | |
SUSPENSION |
| HINGE | MOWER |
| PIN | |
TRUNNIONS | LIFT | LIFT |
| HINGE |
| |
PINS |
|
| ||||
| BRACKET | BRACKETS | PARALLEL | PIN |
| |
|
|
| ||||
RGURE 29 |
|
|
| LINK |
| FIGURE 32 |
21
