TROUBLE SHOOTING
PROBLEM Cause/Remedy
WILL NOT START
WILL NOT TURN OVER
ENGINE CUCKS BUT WON'TSTART
HARD TO START
ENGINE MISSES OR LACKS POWER
ENGINE OVERHEATS
Push Clutch/Brake Pedal into Brake position
Move Attachment Clutch Lever to "Disengaged" position
Fill Tank with Gasoline. Check Fuel Line and Carburetor (clean if necessary). Replace Fuel Filter_Use Fresh Fuel
=P Check Fuse for fault and replace
Recharge or replace Battery ,=," Check Wiring
=r Replace Spark Plug(s) and adjust gap =r. Adjust Valves
Push Clutch/Brake Pedal into brake position =r Charge or replace Battery
w, Move Mower Clutch Lever to "DISENGAGED" position
Replace ignition Switch
wReplace InterlockSwitch(es) Replace Solenoid or Starter Check for fault and replace Fuse
Check all Wire Connections and "Ground" Points
w.Clean Battery Terminals
w.Replace Starter or Solenoid
w.Charge or Replace Battery
Check Wire Connections and "Ground"Points
=r Ptace Throttle Contro! in =FAST" position and run starter several times to clear out gas
Remove Air Filter and clean
fReplace Spark Plug(s) and adjust gap Recharge or replace Battery
Check the Wiring
Drain Fuel Tank and Carburetor. Use Fresh Fuel.=Replace Fuel Filter
Adjust Valves
=r Major Engine Overhaul
Shift to a lower gear or reduce load
='_ Drain Gas Tank and Carburetor° Use Fresh Fuel =r. Remove and clean Air Cleaner
Make necessary Carburetor adjustments w- Clean Air Screen
_" Add or change oil
,r Replace Spark Plug(s) and adjust gap w _ Check for loose wires
w.Replace Fuel Filter
wr Adjust Valves
Major Engine Overhaul
w.Shift to lower gear or reduce load ,r Clean Air Screen
w = Add or change oil
w.Clean Engine Cooling Fins
,r Remove and clean Muffler or replace ,r Remove and clean Air Filter
25