TROUBLESHOOTING CHART
tROUBLESHOOTING CHART
PROBLEMCAUSE
Lossofpower1. Cuttingtoo muchgrass/too fast.
2.Throttle in "CHOKE" position.
3.
14" Dirty air filter.
5.Low oil level/dirty oil.
6.Faulty spark plug.
7.Dirty fuel filter.
8.Stale or dirty fuel,
9.Water in fuel.
10.Spark plug wire loose.
11.Dirty engine air screen/fins.
12.Dirty/clogged muffler. 13.Loose or damaged wiring.
14.Carburetor out of adjustment.
| 15.Engine | valves out of |
| adjustment. | |
Excessive | 1. Worn, | bent or loose blade. |
vibration |
|
|
2.Bent blade mandrel.
3.Loose/damaged part(s).
Enginecontinues | 1. Faulty | |
to run |
| presence control system. |
when operator |
| |
leaves | seat with |
|
with attachment |
| |
clutch | engaged |
|
CORRECTION
1.Set in "Higher Cut" position/ reduce speed.
2.Adjust throttle control.
3.Clean underside of mower housing.
4.Clean/replace air filter.
5.Check oil level/change oil.
6.Clean and regap or change spark plug.
7.Replace fuel filter.
8.Drain fuel tank and refill with fresh gasoline.
9.Drain fuel tank and carbura tor, refill tank with fresh
gasoline and replace fuel filter.
10, Connect and tighten spark plug wire.
11.Clean engine air screen/fins. 12.Clean/replace muffler. 13.Check all wiring.
14.See "To Adjust Carburetor" in Service Adjustments section.
15.Contact a Sears or other qualified service center.
1.Replace blade. Tighten blade bolt.
2.Replace blade mandrel.
3.Tighten loose part(s). Replace damaged parts.
1.Check wiring, switches and connections. If not
contact a Sears or other qualified service center.
Poor cut - uneven 1. | Worn, | bent | or loose blade. | 1. | Replace | blade. | Tighten | ||||||
|
|
|
|
|
|
|
|
| blade | bolt. |
|
| |
2. | Mower | deck | not | level. | 2. | Level | mower | deck. | |||||
3. | Buildup | of | grass, | leaves, | 3. | Clean | underside | of mower | |||||
| and | trash | under | mower. |
| housing. |
|
|
| ||||
4. | Bent | blade | mandrel. | 4. | Replace | blade | mandrel. | ||||||
5. | Clogged mower | deck vent | 5. | Clean | around | mandrels to | |||||||
| holes from | buildup | of |
| open | vent holes. | |||||||
| grass, | leaves, and | trash |
|
|
|
|
|
| ||||
| around | mandrels. |
|
|
|
|
|
|
|
29