Desa CD42M-A2 Electrical Hookup and Remote Receiver Diagram, GAS Supply Testing, GAS Line HOOK-UP

INSTALLATION

Continued

ELECTRICAL HOOKUP AND REMOTE RECEIVER DIAGRAM

An outlet box with two receptacles (see Figure 9) has been supplied for your convenience and is located inside on the lower right side of the fireplace.

The remote control receiver is factory wired and connected to the convertible gas valve as shown in Figure 10.

Outlet Box

Three-prong Plug

Figure 9 - Duplex Outlet

The appliance must be isolated from the gas sup-
ply piping system by closing its individual shutoff
valve during any pressure testing of the gas supply
piping system at test pressures equal to or less than
1/2 psig (3.5 kPa).
The gas control valve is secured underneath the
firebox. Two 1/8" ports are provided on the gas
control valve for pressure test gauge connections
(see Figure 11).
	Pilot Gas Line
	Do Not Kink	To Pilot
Pilot Adjustment
		Burner
ON/OFF
Knob
		To Main
		Burner
Inlet	Flame
Pressure Outlet
	Adjustment Knob
Pressure
Figure 11 - Gas Control Valve

Convertible
Gas Valve	Remote
	Control
	Receiver
Figure 10 - Remote Control Receiver
GAS SUPPLY TESTING
NOTICE: This section is in-
tended as a guide for qualified
technicians installing gas to the
appliance.
WARNING: Do not connect
appliance before pressure test-
ing gas piping. Damage to gas
valve may result and an unsafe
condition may be created.
The appliance and its individual shutoff valve must
be disconnected from the gas supply piping system
during any pressure testing of that system at test
pressures in excess of 1/2 psig (3.5 kPa).

GAS LINE HOOK-UP
WARNING: Gas line hook-
up should be done by your gas
supplier or a qualified service
person.
WARNING: Before you pro-
ceed, make sure your gas supply
is OFF.
An equipment shutoff valve has been included in
the fireplace's gas supply system. However, con-
sider installing an extra shutoff valve outside the
applianceʼs enclosure (check local codes), where
it can be accessed more conveniently with a key
through a wall as shown in Figure 12.
Key	Shutoff
	Valve

Extension

Figure 12- Typical Exterior Wall Gas Shutoff Installation

111916-01F www.desatech.com 9