Generac 004626-1, 004373-2, 004373-2, 004626-1 specification

Section 8 — Notes

Guardian Liquid-cooled 40 kW Generators

Generac® Power Systems, Inc. 55

Image 57

Generac 004626-1, 004373-2, 004373-2, 004626-1 owner manual Guardian Liquid-cooled 40 kW Generators

Contents

Power SYSTEMS, INC Authorized Dealer Location Introduction Installation Safety Rules General InformationMaintenance Section Installation Drawings 56-57 Warranty Back Cover General Hazards Electrical Hazards UNPACKING/INSPECTION Prepackaged Transfer SwitchGenerator Generator AC Connection Systems Specifications Main Circuit BreakerEngine Protective Devices Generator and Load Compatibility Fuel Requirements RecommendationsEngine Conversion to LP GAS Vapor Coolant Emissions Control SystemAIR Fuel Ratio Controller Basic Standby Electric System Standby Generator InstallationNfpa Standards Other Published Standards Pre-Packaged Type Switch Transfer Switch Start Signal ConnectionsGTS Type Engineered Switch Emergency Circuit Isolation Method Battery Installation Preparation Before START-UPVented Batteries Prior to Initial START-UP Using the AUTO/OFF/MANUAL Switch Manual Position OFF PositionAutomatic Transfer Operation Sequence of Automatic Operation Checking the Engine OIL Level Weekly Exercise Cycle Changing the Engine AIR Cleaner Oil and Filter Change ProcedureChanging the Engine OIL and Filter Engine Oil Recommendations Spark Plugs Battery Maintenance Cleaning the Generator Miscellaneous MaintenanceOverload Protection for Engine DC Electrical System DC Fuse OUT of Service Procedure Removal From ServiceReturn To Service SYSTEM/COMPONENT Procedure Frequency Service Schedule Problem Cause Correction Troubleshooting Guide Electrical Data Section Generac Generac Power Systems,Inc Electrical Data Electrical Data Electrical Data Wiring Diagram Customer Connection HRS Power Systems Inc Part NO. QTY. Description Generators Part NO. QTY Description Part NO.QTY Description QTY Description 4640 31 33 Washer Flat 3/8-M10 Zinc Part NO.QTY. Description Exploded Views and Parts Lists Flywhl 4.3L GM SAE Stator Leads Scrolldetail To Engine Flywheel QTY Description Part NO. QTY Description QTY Assembly Cover Access Radiator Copper Brass Gasket Carburetor Adaptor Gasket Carb Impco To Carburetor QTY. Description Support Solenoid NAT GAS QTY. Description To Starter Solenoid RED Black To Engine Block ALT Leads Sensing Wire Siemens FD 3 Pole QTY Description Exploded Views and Parts Lists Part NO. QTY. Description Muffler 2-1/2 INLET/OUTLET Guardian Liquid-cooled 40 kW Generators Installation Drawings 12V Battery see Note Lifting EYE Places This Warranty Shall not Apply to the Following Warranty Schedule