Exploded Views and Parts Lists | Generac 02010-2, 04164-2 specification

Section 6 — Exploded Views and Parts Lists

PRIMEPACT 50 Recreational Vehicle Generator

Base and Pulleys (Model 02010-2) – Drawing No. D1759-A

40 Generac® Power Systems, Inc.

Image 42

Generac 02010-2, 04164-2 owner manual Exploded Views and Parts Lists

Contents

Power SYSTEMS, INC Authorized Service Dealer Location Introduction Part II Installation Instructions Table of Contents General Hazards Electrical Hazards Generator Identification Model 02010-2 PrimepactModel 04164-2 Primepact 50LP Generator Applicability SafetySpecifications Generator AC Connection System Engine OIL Requirements Optional Propane Fuel SystemFuel Consumption Generator Optional Remote START/STOP Panel START/STOP SwitchGenerator Control Panel Fuel Primer Automatic Choke Gasoline only Before Starting the Engine Applying Loads to Generator Starting the GeneratorStopping the Generator SUMMER/WINTER Heat Riser System Protection Systems LOW OIL Pressure SwitchHigh Temperature Switch Do not Overload the Generator Additional Information Checking the Engine OIL Level Changing the Engine OIL AND/OR OIL Filter Cleaning the Foam Precleaner Maintaining the Engine AIR CleanerClean AIR Intake Checking the Engine Spark Plug Spark Arrestor Muffler Cleaning the GeneratorBattery Maintenance Weekly Drive Belt Exercising the Generator OUT of Service Procedure Removal from ServiceReturn to Service Part General Hazards Fire Hazards Equipment Description Purpose and Scope ManualStandards Booklets Generator Engine Operating Speed Major Features and Dimensions Generator Support Location and SupportGenerator Location Suspended Mounting Compartment Construction Generator CompartmentsGenerator Restraint Compartment Size Acoustics Sound Insulating Materials Typical Noise Abatement 2.2.5 Compartment Floor Cutouts Cooling and Ventilating AIR Generator AirflowCooling AIR Inlet Openings Testing the Installation Gasoline Fuel SystemCompensating for Restrictions Generator Fuel Supply Line LP GAS Fuel SystemFuel Tank Flexible Fuel Line Rigid Fuel Lines Vapor Withdrawal Primary RegulatorSome Important Considerations Gaseous Carburetion Excess Flow Valve Exhaust SystemFuel Supply Lines Leakage Tests Mufflers and Spark Arrestors Exhaust System SafetyElectrical Connections Type of Exhaust System Generator AC Connections WiringIsolating Different Power Sources Conduit Power Supply Cord Ground Fault Circuit Interrupters Battery Cables Optional AccessoriesRecommended Battery Battery Cable Connections Before Initial START-UP Post Installation TestsTesting Under Load Remote Panel Models Installation Checklist Troubleshooting Guide Problem Cause Correction Electrical Data Electrical Data Exploded Views and Parts Lists QTY Description Exploded Views and Parts Lists REGULATOR, GAS Fuel Exploded Views and Parts Lists Lower Bearing Carrier Exploded Views and Parts Lists ¼/ M6-LOCK Washer To Starter SCROLL, Flywheel Exploded Views and Parts Lists Piston Ring SET Exploded Views and Parts Lists MANIFOLD, Intake Exploded Views and Parts Lists CARBURETOR, GN 410 L/P Your Warranty Rights and Obligations MANUFACTURER’S Emission Control System Warranty CoveragePURCHASER’S/OWNER’S Warranty Responsibilities Emission Control System Warranty Emission Related Parts Include the Following Warranty Schedule CONSUMER/PERSONAL Applications This Warranty Shall not Apply to the Following