Hearth and Home Technologies 36, 42 D. Service Parts (continued)

Outdoor Lifestyles by Hearth & Home Technologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/11 39

D. Service Parts (continued)Service Parts

06/11

42” Outdoor Woodburning Fireplace

2

1

3

4

5

6

8

9

10

11

12

13

14

15

16 17

7

MONTANA-42, MONTANA-42H

Part number list on following page.

Beginning Manufacturing Date: Sept 2003

Ending Manufacturing Date: Active

Service Parts

06/11

IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement

parts for your appliance please provide model number and serial number. All parts listed

in this manual may be ordered from an authorized dealer.

Stocked

in Depot

ITEM DESCRIPTION COMMENTS PART NUMBER

1Starter Collar 30399

2 Damper Assembly 34454

3 Top Stand Off Qty 4 Req 4044-111

4 Upper Front Face Not replaceable

must order overlay

4017-001

30395

5 Side Column Left 30375

6 Top Door Track 30400

7 Door Clips Qty 2 Req 30407

Tradtional Refractory

8Right Side Refractory 28393

9Back Refractory 28394

10 Left Side Refractory 28393

Hearth Refractory 28391

11 Grate GR21 Y

12 Hearth Pan Pre AK560843 30405

Hearth Stone Retainer Post AK560843 30403

13 Firescreen Rod Qry 2 Req 31375 Y

14 Screen Assembly Qty 2 Req 30371

15 Door Pivet Clip Qty 2 Req 31527

16 Bottom Front Face Not replaceable

must order overlay

4017-001

30393

17 Side column Right 30376

Gas Tube 30412

Smoke Shield 30402

Herringbone refractory available post week 3/04

8Right Side Refractory 4010-013

9Back Refractory 4010-015

10 Left Side Refractory 4010-014

Hearth Refractory 4010-020

MONTANA-42, MONTANA-42H

Beginning Manufacturing Date: Sept 2003

Ending Manufacturing Date: Active

Contents

Main Owners Manual Models: Montana-36 Montana-42 Woodburning Fireplace DO NOT DISCARD Homeowner Reference Information Listing Label Information/Location Congratulations! Table of Contents 1 A. Appliance Certication 2 A. Design and Installation Considerations Moisture Resistance: B. Typical Fireplace System D. Inspect Fireplace and Components C. Tools and Supplies Needed 3 A. Selecting Fireplace Location WARNING Page B. Clearances C. Sidewalls/Surrounds D. Frame the Fireplace E. Chimney Requirements A. Install the Dual Cooling Air Kit 4 B. Secure the Fireplace Position the Fireplace Place the Protective Metal Hearth Strips Level the Fireplace A. Chimney Requirements 5 B. Using Offsets/Returns Table 5.2 C. Assemble the Chimney Sections D. Install the Ceiling Firestops E. Install the Attic Insulation Shield F. Double-check the Chimney Assembly G. Secure the Chimney Ceiling Firestop Straps Optional Additional Support Joint Band (Optional) 6 Figure 6.1 Multiple Chimneys A. Chimney Termination Chimney Termination Requirements (See Figure 6.1) B. Chase Top Mark the Exit Point of the Roof Cut Out the Hole in the Roof Assemble the Chimney Sections Through the Roof Install the Roof Flashing C. Install the Termination Cap Figure 6.6 Installing an ST1175/ST475 Square Termination Cap Figure 6.4 Installing a TR11/TR444 Round Termination Cap TR11/TR444 Round Termination Cap TR11T/TR442 Round Telescoping Termination Cap Outdoor Lifestyles by Hearth & Home Technologies Inc. Montana US-CAN 4039-156 Rev K 7/11 21 TCT1175 Terra Cotta Cap A. Gas Log/Lighter Provisions 7 8 A. Hearth Extension Table 8.1 B. Finishing Material C. Mantel D. Sidewalls/Surrounds E. Glass Doors 9 A. General Information Damper D. Flue Damper B. Outside Air C. Clear Space Near the Fireplace E. Firescreen F. Glass Doors G. Grate H. Wood Fuel Firewood Moisture Seasoning I. Starting a Fire Diagnostics and Problem Solving 10 I cant get a good re going. What am I doing wrong? I dont get enough/any heat from the replace. What can I do about it? The replace burns the wood too fast. What can I do? 1 1 A. Disposal of Ashes B. Chimney Inspection/Cleaning C. Firebox Refractory D. Maintenance Task List E. Chimney Fire 1 2 A. Fireplace Dimensions B. Fireplace Components Description C. Chimney Components ` SLA10 Adapter UD4 Uninsulated Duct CAK5A Chimney Air Kit 13 in. (330 mm) 39-7/8 in. (1013 mm) 28 in. (711 mm) 15-1/4in. (387 mm) 25-1/4 in. (641 mm) Woodburning Termination Cap D. Service Parts Service Parts MONTANA-36, MONTANA-36H Service Parts Part number list on following page. D. Service Parts (continued) MONTANA-42, MONTANA-42H Service Parts Service Parts MONTANA-42, MONTANA-42H Page Page E. Limited Warranty Outdoor Lifestyles by Hearth & Home Technologies, Inc. Limited Warranty Limited Warranty (continued) NOTES F. Contact Information DO NOT DISCARD THIS MANUAL DO NOT DISCARD Please contact your Outdoor Lifestyles dealer with any questions or concerns.