Hearth and Home Technologies 5100I-GD-B, 5100I-NL-B warranty

DO NOT DISCARD THIS MANUAL

NOTICE

• I mportant ope rating

and maintenance in-

structions included.

• Leave this manual with

party responsible for

use and operation.

• Read, understand and

follow these instructions

for safe installation and

operation.

DO NOT

DISCARD

WARNING

If the information in these instruc-

tions is not followed exactly, a re

may result causing property damage,

personal injury, or death.

• Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

• Do not overre - If heater or chimney

connector glows, you are overring.

Overring will void your warranty.

• Comply with all minimum clearances to

combustibles as specied. Failure to

comply may cause house re.

www.quadrare.com

5100-I ACT WOOD INSERT

Advanced Combustion Technology (ACT)

438-0380D September 1, 2008

1445 North Highway

Colville, WA 99114-2008

R

Installation and service of this appliance should

be performed by qualied personnel. Hearth &

Home Technologies recommends NFI certied

professionals, or technicians supervised by an

NFI certied professional.

Fire Risk.

WARNING

For use with solid wood fuel only.

Other fuels may overre and generate

poisonous gases (i.e. carbon monoxide).

HOT SURFACES!

Glass and other surfaces are

hot during operation AND

cool down.

Hot glass will cause

WARNING

• Do not touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in the same room as

appliance

• Alert children and adults to hazards of high temperatures

High temperatures may ignite clothing or other

ammable materials.

• Keep clothing, furniture, draperies and other

combustibles away.

burns.

Model:5100I-GD-B5100I-NL-B

O-T L

Tested and

Listed by

Portland

Oregon USA

OMNI-Test Laboratories, Inc.

CUS

Contents

Main DO NOT DISCARD THIS MANUAL NOTICE burns. 5100-I ACT WOOD INSERT Advanced Combustion Technology (ACT) High temperatures may ignite clothing or other ammable materials. Model: 5100I-GD-B 5100I-NL-B Page September 1, 2008 SAMPLE ACT INSERT Manufactured Date Model / Modle E TABLE OF CONTENTS Section 1: Listing and Code Approvals Section 2: Getting Started Section 3: Dimensions & Clearances Section 4: Installation Considerations 1 5100-I ACT WOOD INSERT 2 . A Design, Installation & Location Considerations C. Negative Pressure D. Flue Draft Considerations F. Inspect Appliance and Components E. Tools And Supplies Needed Page 8 September 1, 2008 438-0380D SIDE VIEW FRONT VIEW A 39-1/8" (994mm) NOTE: Flue Collar: 6 inch (152mm) diameter (ID) Panel Size A B Standard 47 in. 30-1/2 in. Large 51-1/4 in. 34-1/4 in. D Hearth Extension B C FE SideWall Insert 5100-I ACT WOOD INSERT A. Floor Protection USA & Canada B. 4 C. Hearth Extension D. Outside Air Installation E. Blower Cord Location Page 1 Figure 13.1 Figure 13.2 Figure 13.3 September 1, 2008 F. Wiring Diagram G. Optional Offset Adapter 5 A. Venting Components B. Chimney Systems C. Installing Chimney Components D. Chimney Termination Requirements E. 2-10-3 Rule Flat Roof Pitched Roof F. Masonry Fireplace NOTE: G. Factory-Built Zero Clearance Fireplace (USA INSTALLATIONS ONLY) 6 B. Leveling Bolts 7 Cage nut Do not tighten sides until top is locked into place Panel bracket D. Securing Liner to Flue Collar E. Zero Clearance Adjustable Trim Support Size: 12 d x 50 w, 2-10 h ( 8 A. Over-Firing Your Appliance WARNING B. Wood Selection & Storage C. Burning Process PrimaryAir Control Start-UpAir Control D. Air Controls E. Heat Output G. Building A Fire F. Burn Rates I. Opacity (Smoke) H. Blower Operating Instructions Page 9 A. General Maintenance B. Glass Replacement - Door Assembly D. Door Handle Assembly Replacement C. Glass Replacement - Side Window Slide Window In / Out Loosen bolts Remove bolts * Nbr Brick Size qty F. Blower Replacement G. Bafe Removal CORRECT POSITION INCORRECT POSITIONS Ceramic Blanket WARNING H. Correct Bafe & Blanket Placement Ceramic Blanket Back of Firebox Back of Firebox 1. If I cant get a good re going, what am I doing wrong? 2. I smell smoke in the house after we have had a re. What is the cause/what can I do? 3. I smell smoke in the house during operation. What is causing it? 4. I dont get enough/any heat. What can I do about it? 5. The wood burns too fast. What can I do? 6. The blower does not come on when insert reaches set temperate. What can I do? Page 6 September 1, 2008 A. Exploded Views Figure 36.1 - Front Door & Glass Assembly Figure 36.3 - Wood Insert Figure 36.2 -Side Window B. Service Parts & Accessories Accessories Page Page Page E. Warranty Policy Hearth & Home Technologies LIMITED WARRANTY Hearth & Home Technologies LIMITED WARRANTY (Contd) Your Records for Model: 5100-I Wood Insert (ACT)