OPERATION
MACHINE INSTALLATION
UNCRATING MACHINE
Carefully check carton for signs of damage. Report damages at once to carrier.
Check carton contents list below. Contact your distributor for missing items.
1 ± Recovery Dome (stored in battery compartment)
1 ± Recovery Dome Vacuum Hose (stored in recovery tank)
1 ± Battery Tray
2 ± Battery Cables (stored in battery compartment)
1 ± Pumpout Hose (stored in recovery tank)
1 ± Standpipe Screen (stored in recovery tank)
1 ± Solution Tank Fill Port Strainer (stored in recovery tank)
1 ± Spray Bar (installed on machine)
1 ± Battery Charger (Included with Concorde HP Plus Pac 608935) Packaged Separately
3 ± 12V Batteries (Included with Concorde HP Plus Pac 608935; not included with Pac 609256) Packaged Separately
ATTENTION: Battery installation must be accomplished after removing machine from shipping crate.
ATTENTION: DO NOT roll machine off pallet or use a forklift, machine damage will occur. Use a hoist or ramp.
INSTALLING BATTERIES
WARNING: Batteries emit hydrogen gas. Explosion or fire can result. Keep sparks and open flame away. Keep battery compartment open when charging.
FOR SAFETY: When servicing machine, wear protective gloves when handling batteries or battery cables. Avoid contact with battery acid.
Battery Specifications:
Three 12 volt, 215 Ah, deep cycle batteries. Consult with an Authorized Distributor for specific batteries. Maximum battery dimensions are 178mm(7in)W x 380mm(15 in)L x 370mm(14.63 in)H.
1.Before installing batteries pull out the main circuit breaker button to shut off power to machine. Circuit breaker panel is located at rear lower right of machine (Figure 1).
FOR SAFETY: Before leaving or servicing machine, stop on level surface, turn off machine and pull out main circuit breaker button.
FIG. 1
2.Lift battery compartment hood off machine and remove loose battery cables.
3.Carefully install batteries into battery tray with negative posts towards back of machine. (Figure 2).
ATTENTION: Be careful not to drop batteries into compartment, battery and machine housing damage may result.
FIG. 2
Concorde HP Plus (01±00) | Home |
| Find... |
| Go To.. |
| 5 |
|
|
|
|
| |||
|
|
|
|
|
|
|
|