Manuals / Husqvarna / Lawn and Garden / Lawn Mower

Husqvarna 2748 GLS (CA) manual Schematic, Pto Switch, Ignition Switch, SCH12, Optional

Models: 2748 GLS (CA)

1 46

Download 46 pages 54.69 Kb

Page 30

SCHEMATIC

TRACTOR - MODEL NO. 2748GLS (96043005000), PRODUCT NO. 960 43 00-50

SCHEMATIC

SCH12

				BATTERY	SOLENOID
					SOLENOID
	A	RED		RED
		RED		FUSE
AMMETER				FUSE		BLACK
(OPTIONAL)						BLACK
(OPTIONAL)
	WHITE			PTO SWITCH		WHITE
				PTO SWITCH		WHITE
				(DISENGAGED)
S	M	BLACK			H WHITE
B		BLACK
B			C
	A1		C
G	A1
G	A2
L	A2	RED	A		D RED	CLUTCH/BRAKE
		RED

						(PEDAL UP)
			B		E
					BLACK
				BLACK
				BLACK
				BLACK	2	BLACK
				BLACK
					3	BLACK
				BLACK	1	BLACK
					1
					6	GRAY

STARTER

M

ELECTRIC CLUTCH

BLACK

GRAY

REVERSE SWITCH (NOT IN REVERSE)

SEAT SWITCH (NOT OCCUPIED)

C F	H
B E	G
A D
		BLACK
PTO SWITCH
(MATING SIDE)

		JUNCTION
		CONNECTOR
/WHITE				SHORTING
BLACK		CHASSIS		SHORTING
BLACK		CHASSIS		CONNECTOR
				CONNECTOR
		HARNESS
	IGNITION			SPARK
	UNIT			PLUGS GAP
				(2 PLUGS ON
	(OPTIONAL)		TWIN CYL. ENGINES)
	(OPTIONAL)
BLUE	HOUR			BLACK
	METER
FUEL		BLUE		12V	BLACK
LINE				12V
LINE
				POWER OUTLET
BLUE				(OPTIONAL)
	CHARGING SYSTEM OUTPUT
FUEL SHUT-OFF	9 - 1 6 AMP DC @ 3600 RPM
SOLENOID
(IF EQUIPPED)	REGULATOR			STATOR
RED	REGULATOR
RED
ORANGE		28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
		28 VOLTS AC @ 3600 RPM (REGULATOR DISCONNECTED)
	BROWN				BLACK
LIGHT
SWITCH

HEADLIGHTS

IGNITION SWITCH

POSITION	CIRCUIT	“MAKE”

OFF	M+G+A1
RUN/OVERRIDE	B+A1
RUN	B+A1	L+A2
START	B + S + A1

3	6	6	3

2	5	5	2
1	4	4	1

CHASSIS HARNESS		DASH HARNESS
CONNECTOR		CONNECTOR
(MATING SIDE)		29

WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.

NON-REMOVABLE CONNECTIONS

REMOVABLE CONNECTIONS

Image 30

Husqvarna 2748 GLS (CA) manual Schematic, Pto Switch, Ignition Switch, SCH12, Optional

Contents

Ride Mower 2748 GLS CA96043005000 Operators ManualPage I. GENERAL OPERATION SAFETY RULESSafe Operation Practices for Ride-OnMowers II. SLOPE OPERATIONIV. TOWING V. SERVICEIII. CHILDREN SAFETY RULESCUSTOMER RESPONSIBILITIES TABLE OF CONTENTSPRODUCT SPECIFICATIONS 7-13CHECK BATTERY See Fig. ASSEMBLYTOOLS REQUIRED FOR ASSEMBLY ADJUST SEAT See Fig.CHECK FOR PROPER POSITION OF ALL BELTS CHECK TIRE PRESSURECHECK DECK LEVELNESS CHECK BRAKE SYSTEMOPERATION KNOW YOUR TRACTOR OPERATIONFIG. STOPPING HOW TO USE YOUR TRACTORTO SET PARKING BRAKE See Fig. TO USE THROTTLE CONTROL - D See Fig.TO MOVE FORWARD AND BACKWARD See Fig. TO ADJUST MOWER CUTTING HEIGHT See Fig.TO ADJUST GAUGE WHEELS See Fig. TO OPERATE MOWERREVERSE OPERATION SYSTEM ROS SERVICE REMINDER/HOUR METERBEFORE STARTING THE ENGINE TO OPERATE ON HILLSPURGE TRANSMISSION ADD GASOLINETO START ENGINE See Fig. OPERATIONMOWING TIPS OPERATIONFIG. MAINTENANCE MAINTENANCELUBRICATION CHART GENERAL RECOMMENDATIONSBRAKE OPERATION BATTERYTRACTOR TIRESV-BELTS CLEAN AIR SCREENENGINE TRANSAXLE COOLINGENGINE OIL FILTER CLEANINGDECK WASHOUT PORT See Fig. 16B MUFFLERTRACTOR SERVICE AND ADJUSTMENTSTO REMOVE MOWER See Fig. •Depress brake pedal fully and set parking brakeFIG. TO INSTALL MOWER See Figs.SERVICE AND ADJUSTMENTS FIG.FIG. SERVICE AND ADJUSTMENTSC D FIG. FIG.to lower mower TO LEVEL MOWERSERVICE AND ADJUSTMENTS FIG.Tighten adjust nut TO REPLACE MOWER BLADE DRIVE BELT See Fig.SERVICE AND ADJUSTMENTS B to raise mowerFRONT WHEEL TOE-IN/CAMBER TO REPLACE MOTION DRIVE BELT See Fig.TO CHECK BRAKE TO REMOVE WHEEL FOR REPAIRS See Fig.SERVICE AND ADJUSTMENTS TO START ENGINE WITH A WEAK BATTERY See Fig.REPLACING BATTERY See Fig. BATTERYTO ADJUST THROTTLE CONTROL CABLE TO REMOVE HOOD AND GRILL ASSEMBLY See Fig.WIRE TO ADJUST CHOKE CONTROLFUEL SYSTEM STORAGEOTHER ENGINE OILCAUSE TROUBLESHOOTING POINTSPROBLEM CORRECTIONCAUSE TROUBLESHOOTING POINTSPROBLEM CORRECTIONIGNITION SWITCH SCHEMATICPTO SWITCH SCH12ELECTRICAL ELECTRICAL PARTDESCRIPTION CHASSIS chassis-tex_57-gt-husq_r1PART CHASSISPART DESCRIPTIONDRIVE PART DRIVEPART DESCRIPTIONDESCRIPTION STEERING ASSEMBLYPART PARTSPARK ARRESTER KIT ENGINEEngine Power Rating Information PART6 37 6 2 SEAT ASSEMBLY 141 40 10 44 43PART DECALSWHEELS AND TIRES PARTMOWER DECK DESCRIPTION MOWER DECKPART PART97 2 MOWER LIFT7 87 87 90 89 3 91 87 89ONLY RIDE UP AND DOWN HILL NOT ACROSS HILL 15 DEGREES MAX532 41 88-49Rev 1 03-31-08SBW/TH Printed in U.S.ASECTION 4: EXCEPTIONS AND LIMITATIONS WARRANTY STATEMENTSECTION 1: LIMITED WARRANTY SECTION 5: CUSTOMER RESPONSIBILITIES