PRESSURE TESTING
The maximum gas supply pressure for the appliance pres- sure regulator suppliedon this appliance is t 4" W.C. The test pressure for checking this appliance pressure regulator must be at least 6" W.C. for Natural Gas, and at least 11" W.C, for
LP, It is shipped from the factory set for Natural Gas at 5" _/.C.
This appliance and its individual shutoff valve must be dis- connectedfrom the gas supplypiping system duringany pres-
sure testing of that system at test pressures in excess of ½" PSIG (3.5 k Pa).
This appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2"PSIG (3.5 k Pa).
APPLIANCE PRESSURE REGULATOR CONVERSION (See Illustration "D")
If this is a Maxitrol Appliance Pressure Regulator, follow in- structionin illustrationI.f it isa
sure Regulator converted to LP by inserting a coin into the slot in the cap of the appliance pressure regulator and turn countemlockwiseto loosen. Reverse (invert) cap, push down and turnclockwise to lock in place. When finished, the mark- ing "LP" should be visible in the center well of the cap.
CONVERSION TO LP GAS:
This appliance is shipped from the factory equipped for use with Natural Gas. To convert it from Natural Gas for use with LP gas, perform steps 1 through 4.
1.Remove natural gas orifice hoods. Install color coded ori-
rice hoods supplied,located in a pack attached to the outer
plenum area of this appliance.
(See Illustration "E", Below, and LP Gas Conversion
instructions page 6.)
2. Invert cap in convertible appliance pressure regulator (ifso equipped) located at entrance to gas manifold.
3.Adjust air shutters on individual burners for proper flame appearance.
4.Adjust low flame setting at each burner by turning adjust- ment screw in center of valve stem.
To make these conversion adjustments follow the instruc- tions and illustrations ("A" through "E" page
CAUTION
Test all joints for gas leaks with a soap and water solution I or other accepted leak detection means. Never test for gas eaks with an open fame.
This appliance is shipped from the factory with orifice hoods drilledfor use with Natural Gas. To convert from Natural Gas to LP, apply a ½"
the Natural Gas orifice hoods just removed from this appli- ance for future use. Install colorcoded orifice hoods supplied.
MAXlTROLAPPMANCE PRESSURE | _ PLY.D.ODWsN_su(SEEARE Lp GAS CONVERSION INSTRUCTIONS ABOVE AND |
REGULATOR | _T"_}I=S_E_uTO PAGE 6.) TURN CLOCKWISE TO INSTALL. Hold dimension |
,,_LP | REPLPACEINNOAP. specified in illustration"E'. |
_p | I | _ | RNGERPRESSURE | 1/2" OPEN END | |
_ | _TQREMDVEPIN | _ | |||
c0.vE,v- |
|
| / |
L.J ! |
| TURN | |
|
|
| |
|
|
| CLOCKWISE |
| I | TURN _.L_'_ | TO TIGHTEN |
Inversioof pin m ybemos ea | hed | I | COUNTERCLOCKWISE | _ | \ |
byplacingcapona flathorizontsilyaccomplisasurface, |
|
|
|
|
|
shown, applyingfingerpressureto thepinfor | I | TO REMOVE |
| ORIFICE HOOD | |
removaandld replacement. |
|
|
|
|
|
ILLUSTRATION "E"
ILLUSTRATION "D"
_) | |
" _" | PRESSURE |
_,
/_j/
CONTROL SE'n'INGS
The size and type of cookware and the amount and type of
food being cooked will influence the setting needed for best
cooking results.The setting indicated shouldserve as a guide while you become familiar with your cooktop.
begin a cooking operation. Then reduce to a lower setting to
settinUs thg,e HI flame setting to quickly bring foods to a boilz or,to
continue cooking. Novet lea ve food unattended over a Hi fla_e | |
ing operation. Food will not cook any _ | _,_ |
faster when a HI flame setting is used |
|
than that isneeded to maintain a gentle | |
|
|
| boil. Remember, water boils at the same | (/_ | ", |
| |
_ |
| _ | t mperature whe | boiling gently or | f_- | _1 | |
| Med setting isusedthero continue a |
| |||||
NaturalSetting | LPSetting | vigorously. |
|
|
|
| |
Thereversibcapislable | eledeither=LP"or"Natandi"seasilyrecognized Use Lo setting to keep food at serving |
|
|
| |||
bytheraisedcentercoinslot(for atural)orthecenterwell(forLP). | temperatures without further oking. _ | _iI |
|
| |||
ALTERNATE | ILLUSTRATION "D" | You may find that some cooking may L_ | _ | ||||
|
|
| 4 take place if the cookware is covered. | ||||
