Land Pride 311-252M Lubrication

21

10/13/08 RTA10 & RTA15 Series Rotary Tillers 311-252M

Land Pride

Section 4 Maintenance and Lubrication

Table of Contents

20

Multi-purpose

spray lube Multi-purpose

grease lube Multi-purpose

oil lube Intervals in hours at which

lubrication is required.

Lubrication

Legend

Lubrication

Driveline U-Joint

Coat driveline u-joint with grease every 8 hours of

operation

Type of grease = Multi-Purpose

Quantity = Coat Generously

Driveline Shaft

Disconnect driveline shaft from the tractor and slide apart.

Clean and coat the inner tube of the driveline shaft with a

light film of grease and then reassemble.

Type of grease = Multi-Purpose

Quantity = Coat Generously

Chaincase

Type = Recommended: Shell Alvania EP00 Oil

Alternate: GearLube 80-90W EP

Quantity = As required

With tiller on levelground, check oil level in chaincase

byremoving lower plug. Oil should reach the plug hole.

Fill if necessary with Shell Alvania EP OO oil and

retighten plug. Tiller should be levelwhen checking.

14194

As

Required

8

Hrs

20

Hrs

14191

14190

Contents

Main ! Rotary Tillers Table of Contents Important Safety Information . . . . . . . . . . .1 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 Introduction . . . . . . . . . . . . . . . . . . . . . . . .7 Section 1 Assembly and Set-Up . . . . . . . .8 Safety at All Times ! ! Be Aware of Signal Words ! Transport Machinery Safely Use Safety Lights and Devices Practice Safe Maintenance Keep Riders Off Machinery Prepare for Emergencies Wear Protective Equipment Avoid High Pressure Fluids Hazard Safety Labels 818-130C 818-171C 818-858C 818-552C ROTATING DRIVELINE KEEP AWAY! 818-540C 818-552C 818-543C Introduction Table of Contents Serial Number Plate Application Using This Manual Terminology Definitions Owner Assistance ! Driveline Installation Checking Driveline Minimum Length Checking Driveline Maximum Length Section 2 Operating Table of Contents General Notes for Field Operations Operating Check List Transporting Section 2 Operating Table of Contents Parking Operating Instructions RTA10 Tiller Hitch Offset RTA15 Tiller Hitch Sideshift Drive Chain Rear Deflector Skid Shoe Maintenance Tine Replacement ! Driveline Protection Clutches With 4 Adjusting Nuts Clutch Run-In 2-Plate Disassembly 2-Plate Assembly Clutches With 8 Hex Socket Bolts Clutch Run-In Clutch Disassembly & Assembly Shearbolt Protection Shear Bolt and Lock Nut Part Numbers Storage Lubrication Legend Lubrication Driveline U-Joint Driveline Shaft Chaincase Bearing On Right End Of Rotor Shaft Side Plug Gearbox Top Plug Gearbox (10 Series) Top Plug Gearbox (15 Series) Section 5 Specications and Capacities 23 RTA10 Series Rotary Tiller RTA1042 RTA1050 RTA1058 RTA15 Series Rotary Tiller Section 6 Features and Benets Table of Contents RTA10 Series Rotary Tiller Features Benefits 25 Section 6 Features and Benets Table of Contents RTA15 Series Rotary Tiller Features Benefits 26 Section 7 Troubleshooting Table of Contents Problem Cause Solution Machine makes intermittent clicking noise PTO vibrates Gearbox noise is noticeable and constant Torque Values Chart in-tpi 1 Nm ft-lb 3N m ft-lb N m ft-lb mm x pitch N m ft-lb N m ft-lb N m ft-lb Page Section 8 Appendix Table of Contents Warranty