Manuals / Lenovo / Home Audio / Headphones

Lenovo X200 manual Removal steps of USB sub card continued

Models: X200

1 182

Download 182 pages 7.91 Kb

Page 104

Table 26. Removal steps of USB sub card (continued)

Table 26. Removal steps of USB sub card (continued)

Turn the USB sub card over, an then disconnect the cable from the connector.

5

5

When installing: Route the cable as shown in this figure.

96ThinkPad X200 Tablet Hardware Maintenance Manual

Image 104

Lenovo X200 manual Removal steps of USB sub card continued

Contents

ThinkPad X200 Tablet Hardware Maintenance Manual Page ThinkPad X200 Tablet Hardware Maintenance Manual Second Edition November Copyright Lenovo 2008. All rights reservedContents Notices About this manual ThinkPad X200 TabletPage Safety information General safety Electrical safety –Power supply units –Pumps –Blowers and fans Safety inspection guide Grounding requirements Safety notices: multilingual translations Safety noticeDANGER Safety notice8ThinkPad X200 Tablet Hardware Maintenance Manual DANGER Safety noticeThe battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuitit. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery DANGER Safety noticeThe lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery Safety notice If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washingSafety notice Safety noticeDANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter cardDANGER Safety noticeBefore removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables Laser compliance statement DANGER Page Important service information Strategy for replacing FRUsBefore replacing parts 3.Select Downloads and driversImportant notice for replacing a system board How to use error messageStrategy for replacing a hard disk drive Dynamic Configure To Order CTO Using PEWStrategy for replacing FRUs for CTO, CMV, and GAV Product definitionUsing eSupport Using the HMMReplacement FRU Replacement FRUProducts marketed before June Products marketed after JunePage vBe careful not to replace a nondefective FRU General checkoutImportant notes What to do first The following are not covered under warrantyCheckout guide General checkoutDiagnostics using PC-Doctorfor DOS Testing the computerNotes DiagnosticsInteractive Tests PC-Doctorfor Rescue and Recovery PC-Doctorfor WindowsDetecting system information with PC-Doctor Hardware InfoPower system checkout Checking the ac adapterChecking the battery pack Checking operational chargingChecking the backup battery Page Related service information Service Web sitePasswords Power-onpasswordHard-diskpassword Supervisor passwordHow to remove the power-onpassword How to remove the hard-diskpassword5.Select Power-OnPassword A If no SVP has been set6.Select Master HDP Standby mode Power managementScreen blank mode Hibernation mode Symptom-to-FRUindex Numeric error codesTable 1. Numeric error codes continued Symptom or errorTable 1. Numeric error codes continued Symptom or errorTable 1. Numeric error codes continued Symptom or errorError messages Table 2. Error messagesBeep symptoms No-beepsymptomsTable 3. Beep symptoms Table 4. No-beepsymptomsLCD-relatedsymptoms NotesIntermittent problems Undetermined problemsThinkPad X200 Tablet v“Specifications” on pagev“Status indicators” on page v“FRU tests” on page v“FRU replacement notices” on pageSpecifications Table 7. SpecificationsFeature DescriptionTable 7. Specifications continued I/O port ThinkPadStatus indicators Table 8. Status indicatorsIndicator MeaningTable 8. Status indicators continued IndicatorMeaning Blinking greenTable 9. FRU tests FRU testsThe following table shows the test for each FRU Diagnostics --> Other Devices--> Optical Drive Diagnostics --> PM MemoryRun Diagnostics --> ThinkPad Devices --> Fan Table 9. FRU tests continuedFn key combinations Table 10. Fn key combinationsKey combination DescriptionTable 10. Fn key combinations continued Fn+F7FRU replacement notices Screw noticesvPlastic to plastic vLogic card to plasticRetaining serial numbers Restoring the serial number of the system unitRetaining the UUID 3.Select 2. Read S/N data from EEPROM2.From the main menu, select 4. Assign UUID Reading or writing the ECA information Removing and replacing a FRU Before servicing ThinkPad X200 Tablet Removing the SIM card1010 Digitizer pen Table 11. Removal steps of digitizer pen1020 Battery pack Table 12. Removal steps of battery packStep Screw quantityColor TorqueThinkPad X200 Tablet HDD and HDD rubber rails SSD and storage converterThinkPad X200 Tablet 1040 DIMM For access, remove this FRU in orderv“1020 Battery pack” on page Note: Loosen the screwsTable 14. Removal steps of dimm continued 1050 Hinge caps For access, remove this FRU in orderv“1020 Battery pack” on page Table 15. Removal steps of hinge capsTable 15. Removal steps of hinge caps continued ThinkPad X200 Tablet1060 Keyboard StepIcon Screw quantitythe connector and then detachTable 16. Removal steps of keyboard continued 3 3 3When installing 1070 Extension cable card StepScrew quantity Color1080 Palm rest StepIcon Screw quantityTable 18. Removal steps of palm rest continued 1090 Backup battery For access, remove these FRUs in orderv“1020 Battery pack” on page Table 19. Removal steps of backup batteryThinkPad X200 Tablet 1100 PCI Express Mini Card for wireless LAN Full size PCI Express Mini CardStep Screw quantityWhen installing vIn models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable protection tubeHarf size PCI Express Mini Card StepScrew quantity ColorWhen installing ThinkPad X200 Tablet1110 PCI Express Mini Card for wireless WAN StepScrew quantity ColorWhen installing: When you install the card, plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled AUX Note: Step StepScrew quantity ColorThinkPad X200 Tablet 1130 Bluetooth daughter card BDC-2.1 StepScrew quantity ColorThinkPad X200 Tablet When installing: Make sure that the connectoris attached firmly 1140 Keyboard bezel StepScrew quantity ColorStep Screw quantityColor TorqueIn step 1150 I/O card assembly StepScrew quantity ColorNote: The cable is secured with a double-facedadhesive tape 1160 USB sub card StepScrew quantity ColorTable 26. Removal steps of USB sub card continued 1170 LCD assembly StepScrew quantity ColorTable 27. Removal steps of LCD assembly continued StepScrew quantity ColorTable 27. Removal steps of LCD assembly continued ThinkPad X200 TabletTable 27. Removal steps of LCD assembly continued For access, remove these FRUs in order StepScrew quantity ColorStep Screw quantityColor TorqueIn step StepScrew quantity ColorWhen installing assembly continuedStep Screw quantityStep Screw quantityColor TorqueWhen installing from the rubber1190 System board and ExpressCard slot assembly Important notices for handling the system boardBottom ICH I/O Controller Hub CPUMCH Memory Controller Hub Step Screw quantityColor Torque1200 Base cover and speaker assembly Applying labels to the base cover 2010 LCD front bezel Tablet Digitizer Pen modelStep Screw capThinkPad X200 Tablet Touch panel and Tablet Digitizer Pen model StepScrew cap Screw quantityThinkPad X200 Tablet 2020 Micro-Processorcard Note: StepStep Screw quantityColor Torque2030 Inverter card StepScrew quantity Color2040 Hinges StepScrew quantity ColorTable 35. Removal steps of hinge continued 2050 LCD panel and LCD cable Tablet Digitizer Pen model StepScrew cap Screw quantityIn step detach the claws. Then remove the LCD panel4 4 4 4 4 4 4 ThinkPad X200 TabletWhen installing Make sure that the connector Note: Stepwithout the integrated camera, skip step is attached firmlyTurn the LCD panel over, and then remove the LCD cable from the LCD panel Touch panel and Tablet Digitizer Pen model StepScrew quantity ColorNote: Step ThinkPad X200 TabletPage 2060 Integrated camera StepScrew quantity Color2070 LCD rear cover and wireless antenna cables Note: StepStep Screw quantityIn step ThinkPad X200 TabletStep Screw quantityColor TorqueWireless WAN antenna, AUX blue Locations Front view Rear view Rear view tablet modeBottom view Rear view ThinkPad X200 UltraBase Bottom view ThinkPad X200 UltraBase Battery charger behind the flip-downdoorUltraBase eject lever Power button security latch Power button Built-instereo speakersParts list Self-serviceCRUsOptional-serviceCRUs NotesOverall Table 40. Parts list—OverallFRU no RoHSRoHS Table 40. Parts list—OverallcontinuedFRU no Table 40. Parts list—Overallcontinued 42W8049Table 40. Parts list—Overallcontinued 512-MB DDR3-1066SDRAM SO-DIMM PC3-8500cardTable 40. Parts list-Overallcontinued Ericsson F3507g Other - Wireless WAN cardTable 40. Parts list—Overallcontinued 42W8011Table 40. Parts list-Overallcontinued Battery pack, 8 cellTable 40. Parts list—Overallcontinued SATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpmTable 40. Parts list—Overallcontinued SATA hard disk drive, 250 GB, 9.5 mm, 5,400 rpmTable 40. Parts list—Overallcontinued SATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpmTable 40. Parts list—Overallcontinued SATA solid state drive, 64 GB, 8 mmTable 40. Parts list—Overallcontinued DVD/CD-RWcombo drive, 9.5 mmTable 40. Parts list—Overallcontinued Base cover assembly forTable 40. Parts list—Overallcontinued Fan assembly for LVLCD FRUs v“12.1-in.WXGA TFT” on page13 12 11 10 9 1 2 3 4 5 6 b c 812.1-in.WXGA TFT Table 41. Parts list—12.1-in.WXGA TFTFRU no RoHSTable 41. Parts list—12.1-in.WXGA TFT continued LCD panel, 12.1-in.WXGA for Tablet Digitizer PenTable 41. Parts list—12.1-in.WXGA TFT continued Integrated cameraTable 41. Parts list—12.1-in.WXGA TFT continued Wireless LAN/WAN antenna assemblyTable 41. Parts list-12.1-in.WXGA TFT continued Wireless LAN/WAN/USB antenna assemblyTable 41. Parts list—12.1-in.WXGA TFT continued Inverter cardKeyboard Table 42. Parts list—KeyboardLanguage RoHSMiscellaneous parts Table 43. Parts list—MiscellaneouspartsAC adapters Table 44. Parts list—ACadaptersTable 46. Parts list—3-pinpower cords Power cordsTable 45. Parts list—2-pinpower cords Recovery discs Windows XP Tablet DVDsWindows Vista Home Premium 32 bit DVDs Windows Vista Business 32 bit DVDs v7453-CTO v2263-CTO v2266-CTO Windows Vista Business 64 bit DVDsv4184-CTO v7448-CTO v7449-CTO,EKx v7450-CTO,FYx v7453-CTO v2263-CTO v2266-CTO Windows Vista Ultimate 32 bit DVDsv4184-CTO v7448-CTO v7449-CTO v7450-CTO,8Ax Tool Common service toolsTable 52. Parts list—Commonservice tools Notices Lenovo United States, Inc1009 Think Place - Building One Morrisville, NC U.S.A Attention: Lenovo Director of LicensingTrademarks Page Part Number: 45N3683_01 1P P/N: 45N3683_01