Manuals / Lenovo / Home Audio / Headphones

Lenovo manual Step, Screw quantity, Color, Torque, ThinkPad X200 Tablet

Models: X200

1 182

Download 182 pages 7.91 Kb

Page 117

Manual background

Table 29. Removal steps of system board and ExpressCard slot assembly (continued)

Note: The ExpressCard slot assembly is attached to the system board.

Step	Screw (quantity)	Color	Torque

	M2 ⋅ 3.5 mm, wafer-head, nylon-coated (1)	Silver	0.181 Nm
			(1.85 kgfcm)

Turn the system board over, and then remove the ExpressCard slot assembly from the system board.

2

ThinkPad X200 Tablet 109

Image 117

Lenovo manual Step, Screw quantity, Color, Torque, ThinkPad X200 Tablet

Contents

ThinkPad X200 Tablet Hardware Maintenance Manual Page ThinkPad X200 Tablet Hardware Maintenance Manual Copyright Lenovo 2008. All rights reserved Second Edition NovemberContents Notices ThinkPad X200 Tablet About this manualPage Safety information General safety Electrical safety –Power supply units –Pumps –Blowers and fans Safety inspection guide Grounding requirements Safety notice Safety notices: multilingual translationsSafety notice 8ThinkPad X200 Tablet Hardware Maintenance ManualDANGER Safety notice The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuitit. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the batteryDANGER Safety notice The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the batteryDANGER If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing Safety noticeSafety notice Safety noticeDANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter cardSafety notice Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cablesDANGER Laser compliance statement DANGER Page Strategy for replacing FRUs Important service informationBefore replacing parts 3.Select Downloads and driversHow to use error message Strategy for replacing a hard disk driveImportant notice for replacing a system board Using PEW Dynamic Configure To Order CTOStrategy for replacing FRUs for CTO, CMV, and GAV Product definitionUsing the HMM Using eSupportReplacement FRU Replacement FRUProducts marketed before June Products marketed after JunePage General checkout Important notesvBe careful not to replace a nondefective FRU The following are not covered under warranty What to do firstGeneral checkout Checkout guideTesting the computer Diagnostics using PC-Doctorfor DOSDiagnostics Interactive TestsNotes PC-Doctorfor Windows PC-Doctorfor Rescue and RecoveryDetecting system information with PC-Doctor Hardware InfoChecking the ac adapter Power system checkoutChecking operational charging Checking the battery packChecking the backup battery Page Service Web site Related service informationPower-onpassword PasswordsHard-diskpassword Supervisor passwordHow to remove the hard-diskpassword How to remove the power-onpassword5.Select Power-OnPassword A If no SVP has been set6.Select Master HDP Power management Screen blank modeStandby mode Hibernation mode Numeric error codes Symptom-to-FRUindexSymptom or error Table 1. Numeric error codes continuedSymptom or error Table 1. Numeric error codes continuedSymptom or error Table 1. Numeric error codes continuedTable 2. Error messages Error messagesNo-beepsymptoms Beep symptomsTable 3. Beep symptoms Table 4. No-beepsymptomsNotes LCD-relatedsymptomsUndetermined problems Intermittent problemsv“Specifications” on page ThinkPad X200 Tabletv“Status indicators” on page v“FRU tests” on page v“FRU replacement notices” on pageTable 7. Specifications SpecificationsFeature DescriptionI/O port ThinkPad Table 7. Specifications continuedTable 8. Status indicators Status indicatorsIndicator MeaningIndicator Table 8. Status indicators continuedMeaning Blinking greenFRU tests The following table shows the test for each FRUTable 9. FRU tests Diagnostics --> PM Memory Diagnostics --> Other Devices--> Optical DriveRun Diagnostics --> ThinkPad Devices --> Fan Table 9. FRU tests continuedTable 10. Fn key combinations Fn key combinationsKey combination DescriptionFn+F7 Table 10. Fn key combinations continuedScrew notices FRU replacement noticesvPlastic to plastic vLogic card to plasticRestoring the serial number of the system unit Retaining serial numbersRetaining the UUID 3.Select 2. Read S/N data from EEPROM2.From the main menu, select 4. Assign UUID Reading or writing the ECA information Removing and replacing a FRU Removing the SIM card Before servicing ThinkPad X200 TabletTable 11. Removal steps of digitizer pen 1010 Digitizer penTable 12. Removal steps of battery pack 1020 Battery packScrew quantity StepColor TorqueThinkPad X200 Tablet SSD and storage converter HDD and HDD rubber railsThinkPad X200 Tablet For access, remove this FRU in order 1040 DIMMv“1020 Battery pack” on page Note: Loosen the screwsTable 14. Removal steps of dimm continued For access, remove this FRU in order 1050 Hinge capsv“1020 Battery pack” on page Table 15. Removal steps of hinge capsThinkPad X200 Tablet Table 15. Removal steps of hinge caps continuedStep 1060 KeyboardIcon Screw quantityand then detach the connectorTable 16. Removal steps of keyboard continued 3 3 3When installing Step 1070 Extension cable cardScrew quantity ColorStep 1080 Palm restIcon Screw quantityTable 18. Removal steps of palm rest continued For access, remove these FRUs in order 1090 Backup batteryv“1020 Battery pack” on page Table 19. Removal steps of backup batteryThinkPad X200 Tablet Full size PCI Express Mini Card 1100 PCI Express Mini Card for wireless LANStep Screw quantityvIn models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable protection tube When installingStep Harf size PCI Express Mini CardScrew quantity ColorThinkPad X200 Tablet When installingStep 1110 PCI Express Mini Card for wireless WANScrew quantity ColorWhen installing: When you install the card, plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled AUX Step Note: StepScrew quantity ColorThinkPad X200 Tablet Step 1130 Bluetooth daughter card BDC-2.1Screw quantity ColorWhen installing: Make sure that the connector is attached firmlyThinkPad X200 Tablet Step 1140 Keyboard bezelScrew quantity ColorScrew quantity StepColor TorqueIn step Step 1150 I/O card assemblyScrew quantity ColorNote: The cable is secured with a double-facedadhesive tape Step 1160 USB sub cardScrew quantity ColorTable 26. Removal steps of USB sub card continued Step 1170 LCD assemblyScrew quantity ColorStep Table 27. Removal steps of LCD assembly continuedScrew quantity ColorThinkPad X200 Tablet Table 27. Removal steps of LCD assembly continuedTable 27. Removal steps of LCD assembly continued Step For access, remove these FRUs in orderScrew quantity ColorScrew quantity StepColor TorqueStep In stepScrew quantity Colorassembly continued When installingStep Screw quantityScrew quantity StepColor Torquefrom the rubber When installingImportant notices for handling the system board 1190 System board and ExpressCard slot assemblyICH I/O Controller Hub CPU MCH Memory Controller HubBottom Screw quantity StepColor Torque1200 Base cover and speaker assembly Applying labels to the base cover Tablet Digitizer Pen model 2010 LCD front bezelStep Screw capThinkPad X200 Tablet Step Touch panel and Tablet Digitizer Pen modelScrew cap Screw quantityThinkPad X200 Tablet Note: Step 2020 Micro-ProcessorcardScrew quantity StepColor TorqueStep 2030 Inverter cardScrew quantity ColorStep 2040 HingesScrew quantity ColorTable 35. Removal steps of hinge continued 2050 LCD panel and LCD cable Step Tablet Digitizer Pen modelScrew cap Screw quantitydetach the claws. Then remove the LCD panel In step4 4 4 4 4 4 4 ThinkPad X200 TabletNote: Step When installing Make sure that the connectorwithout the integrated camera, skip step is attached firmlyTurn the LCD panel over, and then remove the LCD cable from the LCD panel Step Touch panel and Tablet Digitizer Pen modelScrew quantity ColorThinkPad X200 Tablet Note: StepPage Step 2060 Integrated cameraScrew quantity ColorNote: Step 2070 LCD rear cover and wireless antenna cablesStep Screw quantityThinkPad X200 Tablet In stepScrew quantity StepColor TorqueWireless WAN antenna, AUX blue Locations Front view Rear view tablet mode Rear viewBottom view Rear view ThinkPad X200 UltraBase Battery charger behind the flip-downdoor Bottom view ThinkPad X200 UltraBaseUltraBase eject lever Power button security latch Power button Built-instereo speakersSelf-serviceCRUs Parts listOptional-serviceCRUs NotesTable 40. Parts list—Overall OverallFRU no RoHSTable 40. Parts list—Overallcontinued FRU noRoHS 42W8049 Table 40. Parts list—Overallcontinued512-MB DDR3-1066SDRAM SO-DIMM PC3-8500card Table 40. Parts list—OverallcontinuedEricsson F3507g Other - Wireless WAN card Table 40. Parts list-Overallcontinued42W8011 Table 40. Parts list—OverallcontinuedBattery pack, 8 cell Table 40. Parts list-OverallcontinuedSATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpm Table 40. Parts list—OverallcontinuedSATA hard disk drive, 250 GB, 9.5 mm, 5,400 rpm Table 40. Parts list—OverallcontinuedSATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpm Table 40. Parts list—OverallcontinuedSATA solid state drive, 64 GB, 8 mm Table 40. Parts list—OverallcontinuedDVD/CD-RWcombo drive, 9.5 mm Table 40. Parts list—OverallcontinuedBase cover assembly for Table 40. Parts list—OverallcontinuedFan assembly for LV Table 40. Parts list—Overallcontinuedv“12.1-in.WXGA TFT” on page LCD FRUs13 12 11 10 9 1 2 3 4 5 6 b c 8Table 41. Parts list—12.1-in.WXGA TFT 12.1-in.WXGA TFTFRU no RoHSLCD panel, 12.1-in.WXGA for Tablet Digitizer Pen Table 41. Parts list—12.1-in.WXGA TFT continuedIntegrated camera Table 41. Parts list—12.1-in.WXGA TFT continuedWireless LAN/WAN antenna assembly Table 41. Parts list—12.1-in.WXGA TFT continuedWireless LAN/WAN/USB antenna assembly Table 41. Parts list-12.1-in.WXGA TFT continuedInverter card Table 41. Parts list—12.1-in.WXGA TFT continuedTable 42. Parts list—Keyboard KeyboardLanguage RoHSTable 43. Parts list—Miscellaneousparts Miscellaneous partsTable 44. Parts list—ACadapters AC adaptersPower cords Table 45. Parts list—2-pinpower cordsTable 46. Parts list—3-pinpower cords Windows XP Tablet DVDs Recovery discsWindows Vista Home Premium 32 bit DVDs Windows Vista Business 32 bit DVDs Windows Vista Business 64 bit DVDs v4184-CTO v7448-CTO v7449-CTO,EKx v7450-CTO,FYxv7453-CTO v2263-CTO v2266-CTO Windows Vista Ultimate 32 bit DVDs v4184-CTO v7448-CTO v7449-CTO v7450-CTO,8Axv7453-CTO v2263-CTO v2266-CTO Common service tools Table 52. Parts list—Commonservice toolsTool Lenovo United States, Inc Notices1009 Think Place - Building One Morrisville, NC U.S.A Attention: Lenovo Director of LicensingTrademarks Page 1P P/N: 45N3683_01 Part Number: 45N3683_01