ThinkPad X200 Tablet Hardware Maintenance Manual
Page
ThinkPad X200 Tablet Hardware Maintenance Manual
Second Edition November
Copyright Lenovo 2008. All rights reserved
Contents
Notices
About this manual
ThinkPad X200 Tablet
Page
Safety information
General safety
Electrical safety
–Power supply units –Pumps –Blowers and fans
Safety inspection guide
Grounding requirements
Safety notices: multilingual translations
Safety notice
8ThinkPad X200 Tablet Hardware Maintenance Manual
Safety notice
DANGER
The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuitit. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery
Safety notice
DANGER
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery
Safety notice
DANGER
Safety notice
If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing
Safety notice
Safety notice
DANGER
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card
Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables
Safety notice
DANGER
Laser compliance statement
DANGER
Page
Important service information
Strategy for replacing FRUs
Before replacing parts
3.Select Downloads and drivers
Strategy for replacing a hard disk drive
How to use error message
Important notice for replacing a system board
Dynamic Configure To Order CTO
Using PEW
Strategy for replacing FRUs for CTO, CMV, and GAV
Product definition
Using eSupport
Using the HMM
Replacement FRU
Replacement FRU
Products marketed before June
Products marketed after June
Page
Important notes
General checkout
vBe careful not to replace a nondefective FRU
What to do first
The following are not covered under warranty
Checkout guide
General checkout
Diagnostics using PC-Doctorfor DOS
Testing the computer
Interactive Tests
Diagnostics
Notes
PC-Doctorfor Rescue and Recovery
PC-Doctorfor Windows
Detecting system information with PC-Doctor
Hardware Info
Power system checkout
Checking the ac adapter
Checking the battery pack
Checking operational charging
Checking the backup battery
Page
Related service information
Service Web site
Passwords
Power-onpassword
Hard-diskpassword
Supervisor password
How to remove the power-onpassword
How to remove the hard-diskpassword
5.Select Power-OnPassword
A If no SVP has been set
6.Select Master HDP
Screen blank mode
Power management
Standby mode
Hibernation mode
Symptom-to-FRUindex
Numeric error codes
Table 1. Numeric error codes continued
Symptom or error
Table 1. Numeric error codes continued
Symptom or error
Table 1. Numeric error codes continued
Symptom or error
Error messages
Table 2. Error messages
Beep symptoms
No-beepsymptoms
Table 3. Beep symptoms
Table 4. No-beepsymptoms
LCD-relatedsymptoms
Notes
Intermittent problems
Undetermined problems
ThinkPad X200 Tablet
v“Specifications” on page
v“Status indicators” on page v“FRU tests” on page
v“FRU replacement notices” on page
Specifications
Table 7. Specifications
Feature
Description
Table 7. Specifications continued
I/O port ThinkPad
Status indicators
Table 8. Status indicators
Indicator
Meaning
Table 8. Status indicators continued
Indicator
Meaning
Blinking green
The following table shows the test for each FRU
FRU tests
Table 9. FRU tests
Diagnostics --> Other Devices--> Optical Drive
Diagnostics --> PM Memory
Run Diagnostics --> ThinkPad Devices --> Fan
Table 9. FRU tests continued
Fn key combinations
Table 10. Fn key combinations
Key combination
Description
Table 10. Fn key combinations continued
Fn+F7
FRU replacement notices
Screw notices
vPlastic to plastic
vLogic card to plastic
Retaining serial numbers
Restoring the serial number of the system unit
Retaining the UUID
3.Select 2. Read S/N data from EEPROM
2.From the main menu, select 4. Assign UUID
Reading or writing the ECA information
Removing and replacing a FRU
Before servicing ThinkPad X200 Tablet
Removing the SIM card
1010 Digitizer pen
Table 11. Removal steps of digitizer pen
1020 Battery pack
Table 12. Removal steps of battery pack
Step
Screw quantity
Color
Torque
ThinkPad X200 Tablet
HDD and HDD rubber rails
SSD and storage converter
ThinkPad X200 Tablet
1040 DIMM
For access, remove this FRU in order
v“1020 Battery pack” on page
Note: Loosen the screws
Table 14. Removal steps of dimm continued
1050 Hinge caps
For access, remove this FRU in order
v“1020 Battery pack” on page
Table 15. Removal steps of hinge caps
Table 15. Removal steps of hinge caps continued
ThinkPad X200 Tablet
1060 Keyboard
Step
Icon
Screw quantity
the connector
and then detach
Table 16. Removal steps of keyboard continued
3 3 3
When installing
1070 Extension cable card
Step
Screw quantity
Color
1080 Palm rest
Step
Icon
Screw quantity
Table 18. Removal steps of palm rest continued
1090 Backup battery
For access, remove these FRUs in order
v“1020 Battery pack” on page
Table 19. Removal steps of backup battery
ThinkPad X200 Tablet
1100 PCI Express Mini Card for wireless LAN
Full size PCI Express Mini Card
Step
Screw quantity
When installing
vIn models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable protection tube
Harf size PCI Express Mini Card
Step
Screw quantity
Color
When installing
ThinkPad X200 Tablet
1110 PCI Express Mini Card for wireless WAN
Step
Screw quantity
Color
When installing: When you install the card, plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled AUX
Note: Step
Step
Screw quantity
Color
ThinkPad X200 Tablet
1130 Bluetooth daughter card BDC-2.1
Step
Screw quantity
Color
is attached firmly
When installing: Make sure that the connector
ThinkPad X200 Tablet
1140 Keyboard bezel
Step
Screw quantity
Color
Step
Screw quantity
Color
Torque
In step
1150 I/O card assembly
Step
Screw quantity
Color
Note: The cable is secured with a double-facedadhesive tape
1160 USB sub card
Step
Screw quantity
Color
Table 26. Removal steps of USB sub card continued
1170 LCD assembly
Step
Screw quantity
Color
Table 27. Removal steps of LCD assembly continued
Step
Screw quantity
Color
Table 27. Removal steps of LCD assembly continued
ThinkPad X200 Tablet
Table 27. Removal steps of LCD assembly continued
For access, remove these FRUs in order
Step
Screw quantity
Color
Step
Screw quantity
Color
Torque
In step
Step
Screw quantity
Color
When installing
assembly continued
Step
Screw quantity
Step
Screw quantity
Color
Torque
When installing
from the rubber
1190 System board and ExpressCard slot assembly
Important notices for handling the system board
MCH Memory Controller Hub
ICH I/O Controller Hub CPU
Bottom
Step
Screw quantity
Color
Torque
1200 Base cover and speaker assembly
Applying labels to the base cover
2010 LCD front bezel
Tablet Digitizer Pen model
Step
Screw cap
ThinkPad X200 Tablet
Touch panel and Tablet Digitizer Pen model
Step
Screw cap
Screw quantity
ThinkPad X200 Tablet
2020 Micro-Processorcard
Note: Step
Step
Screw quantity
Color
Torque
2030 Inverter card
Step
Screw quantity
Color
2040 Hinges
Step
Screw quantity
Color
Table 35. Removal steps of hinge continued
2050 LCD panel and LCD cable
Tablet Digitizer Pen model
Step
Screw cap
Screw quantity
In step
detach the claws. Then remove the LCD panel
4 4 4 4 4 4 4
ThinkPad X200 Tablet
When installing Make sure that the connector
Note: Step
without the integrated camera, skip step
is attached firmly
Turn the LCD panel over, and then remove the LCD cable from the LCD panel
Touch panel and Tablet Digitizer Pen model
Step
Screw quantity
Color
Note: Step
ThinkPad X200 Tablet
Page
2060 Integrated camera
Step
Screw quantity
Color
2070 LCD rear cover and wireless antenna cables
Note: Step
Step
Screw quantity
In step
ThinkPad X200 Tablet
Step
Screw quantity
Color
Torque
Wireless WAN antenna, AUX blue
Locations Front view
Rear view
Rear view tablet mode
Bottom view
Rear view ThinkPad X200 UltraBase
Bottom view ThinkPad X200 UltraBase
Battery charger behind the flip-downdoor
UltraBase eject lever Power button security latch
Power button Built-instereo speakers
Parts list
Self-serviceCRUs
Optional-serviceCRUs
Notes
Overall
Table 40. Parts list—Overall
FRU no
RoHS
FRU no
Table 40. Parts list—Overallcontinued
RoHS
Table 40. Parts list—Overallcontinued
42W8049
Table 40. Parts list—Overallcontinued
512-MB DDR3-1066SDRAM SO-DIMM PC3-8500card
Table 40. Parts list-Overallcontinued
Ericsson F3507g Other - Wireless WAN card
Table 40. Parts list—Overallcontinued
42W8011
Table 40. Parts list-Overallcontinued
Battery pack, 8 cell
Table 40. Parts list—Overallcontinued
SATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpm
Table 40. Parts list—Overallcontinued
SATA hard disk drive, 250 GB, 9.5 mm, 5,400 rpm
Table 40. Parts list—Overallcontinued
SATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpm
Table 40. Parts list—Overallcontinued
SATA solid state drive, 64 GB, 8 mm
Table 40. Parts list—Overallcontinued
DVD/CD-RWcombo drive, 9.5 mm
Table 40. Parts list—Overallcontinued
Base cover assembly for
Table 40. Parts list—Overallcontinued
Fan assembly for LV
LCD FRUs
v“12.1-in.WXGA TFT” on page
13 12 11 10 9
1 2 3 4 5 6 b c 8
12.1-in.WXGA TFT
Table 41. Parts list—12.1-in.WXGA TFT
FRU no
RoHS
Table 41. Parts list—12.1-in.WXGA TFT continued
LCD panel, 12.1-in.WXGA for Tablet Digitizer Pen
Table 41. Parts list—12.1-in.WXGA TFT continued
Integrated camera
Table 41. Parts list—12.1-in.WXGA TFT continued
Wireless LAN/WAN antenna assembly
Table 41. Parts list-12.1-in.WXGA TFT continued
Wireless LAN/WAN/USB antenna assembly
Table 41. Parts list—12.1-in.WXGA TFT continued
Inverter card
Keyboard
Table 42. Parts list—Keyboard
Language
RoHS
Miscellaneous parts
Table 43. Parts list—Miscellaneousparts
AC adapters
Table 44. Parts list—ACadapters
Table 45. Parts list—2-pinpower cords
Power cords
Table 46. Parts list—3-pinpower cords
Recovery discs
Windows XP Tablet DVDs
Windows Vista Home Premium 32 bit DVDs
Windows Vista Business 32 bit DVDs
v4184-CTO v7448-CTO v7449-CTO,EKx v7450-CTO,FYx
Windows Vista Business 64 bit DVDs
v7453-CTO v2263-CTO v2266-CTO
v4184-CTO v7448-CTO v7449-CTO v7450-CTO,8Ax
Windows Vista Ultimate 32 bit DVDs
v7453-CTO v2263-CTO v2266-CTO
Table 52. Parts list—Commonservice tools
Common service tools
Tool
Notices
Lenovo United States, Inc
1009 Think Place - Building One Morrisville, NC
U.S.A Attention: Lenovo Director of Licensing
Trademarks
Page
Part Number: 45N3683_01
1P P/N: 45N3683_01