Manuals / Lenovo / Home Audio / Headphones

Lenovo X200 manual Notices

Models: X200

1 182

Page 6

Parts list	.	. .	. . . .	.	.	139	Recovery discs	.	.	.	165
Overall	.	. .	. . . .	.	.	140	Common service tools	.	.	.	170
LCD FRUs . . . .	.	. .	. . . .	.	.	154
Keyboard	.	. .	. . . .	.	.	161	Notices	.	.	171
Miscellaneous parts .	. . .		. . . .	.	.	162	Trademarks	.	.	.	172
AC adapters. . . .	.	. .	. . . .	.	.	163	Trademarks	.	.	.	172
AC adapters. . . .	.	. .	. . . .	.	.	163
Power cords . . . .	.	. .	. . . .	.	.	164

ivThinkPad X200 Tablet Hardware Maintenance Manual

Page 6

Image 6

Contents

ThinkPad X200 Tablet Hardware Maintenance Manual Page ThinkPad X200 Tablet Hardware Maintenance Manual Second Edition November Copyright Lenovo 2008. All rights reservedContents Notices About this manual ThinkPad X200 TabletPage Safety information General safety Electrical safety –Power supply units –Pumps –Blowers and fans Safety inspection guide Grounding requirements Safety notices: multilingual translations Safety noticeSafety notice 8ThinkPad X200 Tablet Hardware Maintenance ManualDANGER Safety notice The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuitit. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the batteryDANGER Safety notice The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the batteryDANGER Safety notice If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washingDANGER Safety noticeSafety notice To avoid shock, do not remove the plastic cover that protects the lower part of the inverter cardSafety notice Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cablesDANGER Laser compliance statement DANGER Page Before replacing parts Important service informationStrategy for replacing FRUs 3.Select Downloads and driversHow to use error message Strategy for replacing a hard disk driveImportant notice for replacing a system board Strategy for replacing FRUs for CTO, CMV, and GAV Dynamic Configure To Order CTOUsing PEW Product definitionUsing eSupport Using the HMMProducts marketed before June Replacement FRUReplacement FRU Products marketed after JunePage General checkout Important notesvBe careful not to replace a nondefective FRU What to do first The following are not covered under warrantyCheckout guide General checkoutDiagnostics using PC-Doctorfor DOS Testing the computerDiagnostics Interactive TestsNotes Detecting system information with PC-Doctor PC-Doctorfor Rescue and RecoveryPC-Doctorfor Windows Hardware InfoPower system checkout Checking the ac adapterChecking the battery pack Checking operational chargingChecking the backup battery Page Related service information Service Web siteHard-diskpassword PasswordsPower-onpassword Supervisor password5.Select Power-OnPassword How to remove the power-onpasswordHow to remove the hard-diskpassword A If no SVP has been set6.Select Master HDP Power management Screen blank modeStandby mode Hibernation mode Symptom-to-FRUindex Numeric error codesTable 1. Numeric error codes continued Symptom or errorTable 1. Numeric error codes continued Symptom or errorTable 1. Numeric error codes continued Symptom or errorError messages Table 2. Error messagesTable 3. Beep symptoms Beep symptomsNo-beepsymptoms Table 4. No-beepsymptomsLCD-relatedsymptoms NotesIntermittent problems Undetermined problemsv“Status indicators” on page v“FRU tests” on page ThinkPad X200 Tabletv“Specifications” on page v“FRU replacement notices” on pageFeature SpecificationsTable 7. Specifications DescriptionTable 7. Specifications continued I/O port ThinkPadIndicator Status indicatorsTable 8. Status indicators MeaningMeaning Table 8. Status indicators continuedIndicator Blinking greenFRU tests The following table shows the test for each FRUTable 9. FRU tests Run Diagnostics --> ThinkPad Devices --> Fan Diagnostics --> Other Devices--> Optical DriveDiagnostics --> PM Memory Table 9. FRU tests continuedKey combination Fn key combinationsTable 10. Fn key combinations DescriptionTable 10. Fn key combinations continued Fn+F7vPlastic to plastic FRU replacement noticesScrew notices vLogic card to plasticRetaining the UUID Retaining serial numbersRestoring the serial number of the system unit 3.Select 2. Read S/N data from EEPROM2.From the main menu, select 4. Assign UUID Reading or writing the ECA information Removing and replacing a FRU Before servicing ThinkPad X200 Tablet Removing the SIM card1010 Digitizer pen Table 11. Removal steps of digitizer pen1020 Battery pack Table 12. Removal steps of battery packColor StepScrew quantity TorqueThinkPad X200 Tablet HDD and HDD rubber rails SSD and storage converterThinkPad X200 Tablet v“1020 Battery pack” on page 1040 DIMMFor access, remove this FRU in order Note: Loosen the screwsTable 14. Removal steps of dimm continued v“1020 Battery pack” on page 1050 Hinge capsFor access, remove this FRU in order Table 15. Removal steps of hinge capsTable 15. Removal steps of hinge caps continued ThinkPad X200 TabletIcon 1060 KeyboardStep Screw quantityTable 16. Removal steps of keyboard continued the connectorand then detach 3 3 3When installing Screw quantity 1070 Extension cable cardStep ColorIcon 1080 Palm restStep Screw quantityTable 18. Removal steps of palm rest continued v“1020 Battery pack” on page 1090 Backup batteryFor access, remove these FRUs in order Table 19. Removal steps of backup batteryThinkPad X200 Tablet Step 1100 PCI Express Mini Card for wireless LANFull size PCI Express Mini Card Screw quantityWhen installing vIn models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable protection tubeScrew quantity Harf size PCI Express Mini CardStep ColorWhen installing ThinkPad X200 TabletScrew quantity 1110 PCI Express Mini Card for wireless WANStep ColorWhen installing: When you install the card, plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled AUX Screw quantity Note: StepStep ColorThinkPad X200 Tablet Screw quantity 1130 Bluetooth daughter card BDC-2.1Step ColorWhen installing: Make sure that the connector is attached firmlyThinkPad X200 Tablet Screw quantity 1140 Keyboard bezelStep ColorColor StepScrew quantity TorqueIn step Screw quantity 1150 I/O card assemblyStep ColorNote: The cable is secured with a double-facedadhesive tape Screw quantity 1160 USB sub cardStep ColorTable 26. Removal steps of USB sub card continued Screw quantity 1170 LCD assemblyStep ColorScrew quantity Table 27. Removal steps of LCD assembly continuedStep ColorTable 27. Removal steps of LCD assembly continued ThinkPad X200 TabletTable 27. Removal steps of LCD assembly continued Screw quantity For access, remove these FRUs in orderStep ColorColor StepScrew quantity TorqueScrew quantity In stepStep ColorStep When installingassembly continued Screw quantityColor StepScrew quantity TorqueWhen installing from the rubber1190 System board and ExpressCard slot assembly Important notices for handling the system boardICH I/O Controller Hub CPU MCH Memory Controller HubBottom Color StepScrew quantity Torque1200 Base cover and speaker assembly Applying labels to the base cover Step 2010 LCD front bezelTablet Digitizer Pen model Screw capThinkPad X200 Tablet Screw cap Touch panel and Tablet Digitizer Pen modelStep Screw quantityThinkPad X200 Tablet 2020 Micro-Processorcard Note: StepColor StepScrew quantity TorqueScrew quantity 2030 Inverter cardStep ColorScrew quantity 2040 HingesStep ColorTable 35. Removal steps of hinge continued 2050 LCD panel and LCD cable Screw cap Tablet Digitizer Pen modelStep Screw quantity4 4 4 4 4 4 4 In stepdetach the claws. Then remove the LCD panel ThinkPad X200 Tabletwithout the integrated camera, skip step When installing Make sure that the connectorNote: Step is attached firmlyTurn the LCD panel over, and then remove the LCD cable from the LCD panel Screw quantity Touch panel and Tablet Digitizer Pen modelStep ColorNote: Step ThinkPad X200 TabletPage Screw quantity 2060 Integrated cameraStep ColorStep 2070 LCD rear cover and wireless antenna cablesNote: Step Screw quantityIn step ThinkPad X200 TabletColor StepScrew quantity TorqueWireless WAN antenna, AUX blue Locations Front view Rear view Rear view tablet modeBottom view Rear view ThinkPad X200 UltraBase UltraBase eject lever Power button security latch Bottom view ThinkPad X200 UltraBaseBattery charger behind the flip-downdoor Power button Built-instereo speakersOptional-serviceCRUs Parts listSelf-serviceCRUs NotesFRU no OverallTable 40. Parts list—Overall RoHSTable 40. Parts list—Overallcontinued FRU noRoHS Table 40. Parts list—Overallcontinued 42W8049Table 40. Parts list—Overallcontinued 512-MB DDR3-1066SDRAM SO-DIMM PC3-8500cardTable 40. Parts list-Overallcontinued Ericsson F3507g Other - Wireless WAN cardTable 40. Parts list—Overallcontinued 42W8011Table 40. Parts list-Overallcontinued Battery pack, 8 cellTable 40. Parts list—Overallcontinued SATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpmTable 40. Parts list—Overallcontinued SATA hard disk drive, 250 GB, 9.5 mm, 5,400 rpmTable 40. Parts list—Overallcontinued SATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpmTable 40. Parts list—Overallcontinued SATA solid state drive, 64 GB, 8 mmTable 40. Parts list—Overallcontinued DVD/CD-RWcombo drive, 9.5 mmTable 40. Parts list—Overallcontinued Base cover assembly forTable 40. Parts list—Overallcontinued Fan assembly for LV13 12 11 10 9 LCD FRUsv“12.1-in.WXGA TFT” on page 1 2 3 4 5 6 b c 8FRU no 12.1-in.WXGA TFTTable 41. Parts list—12.1-in.WXGA TFT RoHSTable 41. Parts list-12.1-in.WXGA TFT continued LCD panel, 12.1-in.WXGA for Tablet Digitizer PenTable 41. Parts list—12.1-in.WXGA TFT continued Integrated cameraTable 41. Parts list—12.1-in.WXGA TFT continued Wireless LAN/WAN antenna assemblyTable 41. Parts list-12.1-in.WXGA TFT continued Wireless LAN/WAN/USB antenna assemblyTable 41. Parts list—12.1-in.WXGA TFT continued Inverter cardLanguage KeyboardTable 42. Parts list-Keyboard RoHSMiscellaneous parts Table 43. Parts list—MiscellaneouspartsAC adapters Table 44. Parts list—ACadaptersPower cords Table 45. Parts list—2-pinpower cordsTable 46. Parts list—3-pinpower cords Recovery discs Windows XP Tablet DVDsWindows Vista Home Premium 32 bit DVDs Windows Vista Business 32 bit DVDs Windows Vista Business 64 bit DVDs v4184-CTO v7448-CTO v7449-CTO,EKx v7450-CTO,FYxv7453-CTO v2263-CTO v2266-CTO Windows Vista Ultimate 32 bit DVDs v4184-CTO v7448-CTO v7449-CTO v7450-CTO,8Axv7453-CTO v2263-CTO v2266-CTO Common service tools Table 52. Parts list—Commonservice toolsTool 1009 Think Place - Building One Morrisville, NC NoticesLenovo United States, Inc U.S.A Attention: Lenovo Director of LicensingTrademarks Page Part Number: 45N3683_01 1P P/N: 45N3683_01