Manuals / Lenovo / Home Audio / Headphones

Lenovo manual ThinkPad X200 Tablet

Models: X200

1 182

Download 182 pages 7.91 Kb

Page 87

Manual background

Table 19. Removal steps of backup battery (continued)

3

2

When installing: Make sure that the battery connector is attached firmly.

ThinkPad X200 Tablet 79

Image 87

Lenovo manual ThinkPad X200 Tablet

Contents

ThinkPad X200 Tablet Hardware Maintenance Manual Page ThinkPad X200 Tablet Hardware Maintenance Manual Copyright Lenovo 2008. All rights reserved Second Edition NovemberContents Notices ThinkPad X200 Tablet About this manualPage Safety information General safety Electrical safety –Power supply units –Pumps –Blowers and fans Safety inspection guide Grounding requirements Safety notice Safety notices: multilingual translationsSafety notice 8ThinkPad X200 Tablet Hardware Maintenance ManualDANGER Safety notice The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuitit. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the batteryDANGER Safety notice The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the batteryDANGER If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing Safety noticeTo avoid shock, do not remove the plastic cover that protects the lower part of the inverter card Safety noticeSafety notice DANGERSafety notice Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cablesDANGER Laser compliance statement DANGER Page 3.Select Downloads and drivers Important service informationStrategy for replacing FRUs Before replacing partsHow to use error message Strategy for replacing a hard disk driveImportant notice for replacing a system board Product definition Dynamic Configure To Order CTOUsing PEW Strategy for replacing FRUs for CTO, CMV, and GAVUsing the HMM Using eSupportProducts marketed after June Replacement FRUReplacement FRU Products marketed before JunePage General checkout Important notesvBe careful not to replace a nondefective FRU The following are not covered under warranty What to do firstGeneral checkout Checkout guideTesting the computer Diagnostics using PC-Doctorfor DOSDiagnostics Interactive TestsNotes Hardware Info PC-Doctorfor Rescue and RecoveryPC-Doctorfor Windows Detecting system information with PC-DoctorChecking the ac adapter Power system checkoutChecking operational charging Checking the battery packChecking the backup battery Page Service Web site Related service informationSupervisor password PasswordsPower-onpassword Hard-diskpasswordA If no SVP has been set How to remove the power-onpasswordHow to remove the hard-diskpassword 5.Select Power-OnPassword6.Select Master HDP Power management Screen blank modeStandby mode Hibernation mode Numeric error codes Symptom-to-FRUindexSymptom or error Table 1. Numeric error codes continuedSymptom or error Table 1. Numeric error codes continuedSymptom or error Table 1. Numeric error codes continuedTable 2. Error messages Error messagesTable 4. No-beepsymptoms Beep symptomsNo-beepsymptoms Table 3. Beep symptomsNotes LCD-relatedsymptomsUndetermined problems Intermittent problemsv“FRU replacement notices” on page ThinkPad X200 Tabletv“Specifications” on page v“Status indicators” on page v“FRU tests” on pageDescription SpecificationsTable 7. Specifications FeatureI/O port ThinkPad Table 7. Specifications continuedMeaning Status indicatorsTable 8. Status indicators IndicatorBlinking green Table 8. Status indicators continuedIndicator MeaningFRU tests The following table shows the test for each FRUTable 9. FRU tests Table 9. FRU tests continued Diagnostics --> Other Devices--> Optical DriveDiagnostics --> PM Memory Run Diagnostics --> ThinkPad Devices --> FanDescription Fn key combinationsTable 10. Fn key combinations Key combinationFn+F7 Table 10. Fn key combinations continuedvLogic card to plastic FRU replacement noticesScrew notices vPlastic to plastic3.Select 2. Read S/N data from EEPROM Retaining serial numbersRestoring the serial number of the system unit Retaining the UUID2.From the main menu, select 4. Assign UUID Reading or writing the ECA information Removing and replacing a FRU Removing the SIM card Before servicing ThinkPad X200 TabletTable 11. Removal steps of digitizer pen 1010 Digitizer penTable 12. Removal steps of battery pack 1020 Battery packTorque StepScrew quantity ColorThinkPad X200 Tablet SSD and storage converter HDD and HDD rubber railsThinkPad X200 Tablet Note: Loosen the screws 1040 DIMMFor access, remove this FRU in order v“1020 Battery pack” on pageTable 14. Removal steps of dimm continued Table 15. Removal steps of hinge caps 1050 Hinge capsFor access, remove this FRU in order v“1020 Battery pack” on pageThinkPad X200 Tablet Table 15. Removal steps of hinge caps continuedScrew quantity 1060 KeyboardStep Icon3 3 3 the connectorand then detach Table 16. Removal steps of keyboard continuedWhen installing Color 1070 Extension cable cardStep Screw quantityScrew quantity 1080 Palm restStep IconTable 18. Removal steps of palm rest continued Table 19. Removal steps of backup battery 1090 Backup batteryFor access, remove these FRUs in order v“1020 Battery pack” on pageThinkPad X200 Tablet Screw quantity 1100 PCI Express Mini Card for wireless LANFull size PCI Express Mini Card StepvIn models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable protection tube When installingColor Harf size PCI Express Mini CardStep Screw quantityThinkPad X200 Tablet When installingColor 1110 PCI Express Mini Card for wireless WANStep Screw quantityWhen installing: When you install the card, plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled AUX Color Note: StepStep Screw quantityThinkPad X200 Tablet Color 1130 Bluetooth daughter card BDC-2.1Step Screw quantityWhen installing: Make sure that the connector is attached firmlyThinkPad X200 Tablet Color 1140 Keyboard bezelStep Screw quantityTorque StepScrew quantity ColorIn step Color 1150 I/O card assemblyStep Screw quantityNote: The cable is secured with a double-facedadhesive tape Color 1160 USB sub cardStep Screw quantityTable 26. Removal steps of USB sub card continued Color 1170 LCD assemblyStep Screw quantityColor Table 27. Removal steps of LCD assembly continuedStep Screw quantityThinkPad X200 Tablet Table 27. Removal steps of LCD assembly continuedTable 27. Removal steps of LCD assembly continued Color For access, remove these FRUs in orderStep Screw quantityTorque StepScrew quantity ColorColor In stepStep Screw quantityScrew quantity When installingassembly continued StepTorque StepScrew quantity Colorfrom the rubber When installingImportant notices for handling the system board 1190 System board and ExpressCard slot assemblyICH I/O Controller Hub CPU MCH Memory Controller HubBottom Torque StepScrew quantity Color1200 Base cover and speaker assembly Applying labels to the base cover Screw cap 2010 LCD front bezelTablet Digitizer Pen model StepThinkPad X200 Tablet Screw quantity Touch panel and Tablet Digitizer Pen modelStep Screw capThinkPad X200 Tablet Note: Step 2020 Micro-ProcessorcardTorque StepScrew quantity ColorColor 2030 Inverter cardStep Screw quantityColor 2040 HingesStep Screw quantityTable 35. Removal steps of hinge continued 2050 LCD panel and LCD cable Screw quantity Tablet Digitizer Pen modelStep Screw capThinkPad X200 Tablet In stepdetach the claws. Then remove the LCD panel 4 4 4 4 4 4 4is attached firmly When installing Make sure that the connectorNote: Step without the integrated camera, skip stepTurn the LCD panel over, and then remove the LCD cable from the LCD panel Color Touch panel and Tablet Digitizer Pen modelStep Screw quantityThinkPad X200 Tablet Note: StepPage Color 2060 Integrated cameraStep Screw quantityScrew quantity 2070 LCD rear cover and wireless antenna cablesNote: Step StepThinkPad X200 Tablet In stepTorque StepScrew quantity ColorWireless WAN antenna, AUX blue Locations Front view Rear view tablet mode Rear viewBottom view Rear view ThinkPad X200 UltraBase Power button Built-instereo speakers Bottom view ThinkPad X200 UltraBaseBattery charger behind the flip-downdoor UltraBase eject lever Power button security latchNotes Parts listSelf-serviceCRUs Optional-serviceCRUsRoHS OverallTable 40. Parts list—Overall FRU noTable 40. Parts list—Overallcontinued FRU noRoHS 42W8049 Table 40. Parts list—Overallcontinued512-MB DDR3-1066SDRAM SO-DIMM PC3-8500card Table 40. Parts list—OverallcontinuedEricsson F3507g Other - Wireless WAN card Table 40. Parts list-Overallcontinued42W8011 Table 40. Parts list—OverallcontinuedBattery pack, 8 cell Table 40. Parts list-OverallcontinuedSATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpm Table 40. Parts list—OverallcontinuedSATA hard disk drive, 250 GB, 9.5 mm, 5,400 rpm Table 40. Parts list—OverallcontinuedSATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpm Table 40. Parts list—OverallcontinuedSATA solid state drive, 64 GB, 8 mm Table 40. Parts list—OverallcontinuedDVD/CD-RWcombo drive, 9.5 mm Table 40. Parts list—OverallcontinuedBase cover assembly for Table 40. Parts list—OverallcontinuedFan assembly for LV Table 40. Parts list—Overallcontinued1 2 3 4 5 6 b c 8 LCD FRUsv“12.1-in.WXGA TFT” on page 13 12 11 10 9RoHS 12.1-in.WXGA TFTTable 41. Parts list—12.1-in.WXGA TFT FRU noLCD panel, 12.1-in.WXGA for Tablet Digitizer Pen Table 41. Parts list-12.1-in.WXGA TFT continuedIntegrated camera Table 41. Parts list—12.1-in.WXGA TFT continuedWireless LAN/WAN antenna assembly Table 41. Parts list—12.1-in.WXGA TFT continuedWireless LAN/WAN/USB antenna assembly Table 41. Parts list-12.1-in.WXGA TFT continuedInverter card Table 41. Parts list—12.1-in.WXGA TFT continuedRoHS KeyboardTable 42. Parts list-Keyboard LanguageTable 43. Parts list—Miscellaneousparts Miscellaneous partsTable 44. Parts list—ACadapters AC adaptersPower cords Table 45. Parts list—2-pinpower cordsTable 46. Parts list—3-pinpower cords Windows XP Tablet DVDs Recovery discsWindows Vista Home Premium 32 bit DVDs Windows Vista Business 32 bit DVDs Windows Vista Business 64 bit DVDs v4184-CTO v7448-CTO v7449-CTO,EKx v7450-CTO,FYxv7453-CTO v2263-CTO v2266-CTO Windows Vista Ultimate 32 bit DVDs v4184-CTO v7448-CTO v7449-CTO v7450-CTO,8Axv7453-CTO v2263-CTO v2266-CTO Common service tools Table 52. Parts list—Commonservice toolsTool U.S.A Attention: Lenovo Director of Licensing NoticesLenovo United States, Inc 1009 Think Place - Building One Morrisville, NCTrademarks Page 1P P/N: 45N3683_01 Part Number: 45N3683_01