ThinkPad X200 Tablet Hardware Maintenance Manual
Page
ThinkPad X200 Tablet Hardware Maintenance Manual
Second Edition November
Copyright Lenovo 2008. All rights reserved
Contents
Notices
About this manual
ThinkPad X200 Tablet
Page
Safety information
General safety
Electrical safety
–Power supply units –Pumps –Blowers and fans
Safety inspection guide
Grounding requirements
Safety notices: multilingual translations
Safety notice
DANGER
Safety notice
8ThinkPad X200 Tablet Hardware Maintenance Manual
DANGER
Safety notice
The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuitit. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery
DANGER
Safety notice
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery
Safety notice
If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing
DANGER
Safety notice
Safety notice
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card
DANGER
Safety notice
Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables
Laser compliance statement
DANGER
Page
Before replacing parts
Important service information
Strategy for replacing FRUs
3.Select Downloads and drivers
Important notice for replacing a system board
How to use error message
Strategy for replacing a hard disk drive
Strategy for replacing FRUs for CTO, CMV, and GAV
Dynamic Configure To Order CTO
Using PEW
Product definition
Using eSupport
Using the HMM
Products marketed before June
Replacement FRU
Replacement FRU
Products marketed after June
Page
vBe careful not to replace a nondefective FRU
General checkout
Important notes
What to do first
The following are not covered under warranty
Checkout guide
General checkout
Diagnostics using PC-Doctorfor DOS
Testing the computer
Notes
Diagnostics
Interactive Tests
Detecting system information with PC-Doctor
PC-Doctorfor Rescue and Recovery
PC-Doctorfor Windows
Hardware Info
Power system checkout
Checking the ac adapter
Checking the battery pack
Checking operational charging
Checking the backup battery
Page
Related service information
Service Web site
Hard-diskpassword
Passwords
Power-onpassword
Supervisor password
5.Select Power-OnPassword
How to remove the power-onpassword
How to remove the hard-diskpassword
A If no SVP has been set
6.Select Master HDP
Standby mode
Power management
Screen blank mode
Hibernation mode
Symptom-to-FRUindex
Numeric error codes
Table 1. Numeric error codes continued
Symptom or error
Table 1. Numeric error codes continued
Symptom or error
Table 1. Numeric error codes continued
Symptom or error
Error messages
Table 2. Error messages
Table 3. Beep symptoms
Beep symptoms
No-beepsymptoms
Table 4. No-beepsymptoms
LCD-relatedsymptoms
Notes
Intermittent problems
Undetermined problems
v“Status indicators” on page v“FRU tests” on page
ThinkPad X200 Tablet
v“Specifications” on page
v“FRU replacement notices” on page
Feature
Specifications
Table 7. Specifications
Description
Table 7. Specifications continued
I/O port ThinkPad
Indicator
Status indicators
Table 8. Status indicators
Meaning
Meaning
Table 8. Status indicators continued
Indicator
Blinking green
Table 9. FRU tests
FRU tests
The following table shows the test for each FRU
Run Diagnostics --> ThinkPad Devices --> Fan
Diagnostics --> Other Devices--> Optical Drive
Diagnostics --> PM Memory
Table 9. FRU tests continued
Key combination
Fn key combinations
Table 10. Fn key combinations
Description
Table 10. Fn key combinations continued
Fn+F7
vPlastic to plastic
FRU replacement notices
Screw notices
vLogic card to plastic
Retaining the UUID
Retaining serial numbers
Restoring the serial number of the system unit
3.Select 2. Read S/N data from EEPROM
2.From the main menu, select 4. Assign UUID
Reading or writing the ECA information
Removing and replacing a FRU
Before servicing ThinkPad X200 Tablet
Removing the SIM card
1010 Digitizer pen
Table 11. Removal steps of digitizer pen
1020 Battery pack
Table 12. Removal steps of battery pack
Color
Step
Screw quantity
Torque
ThinkPad X200 Tablet
HDD and HDD rubber rails
SSD and storage converter
ThinkPad X200 Tablet
v“1020 Battery pack” on page
1040 DIMM
For access, remove this FRU in order
Note: Loosen the screws
Table 14. Removal steps of dimm continued
v“1020 Battery pack” on page
1050 Hinge caps
For access, remove this FRU in order
Table 15. Removal steps of hinge caps
Table 15. Removal steps of hinge caps continued
ThinkPad X200 Tablet
Icon
1060 Keyboard
Step
Screw quantity
Table 16. Removal steps of keyboard continued
the connector
and then detach
3 3 3
When installing
Screw quantity
1070 Extension cable card
Step
Color
Icon
1080 Palm rest
Step
Screw quantity
Table 18. Removal steps of palm rest continued
v“1020 Battery pack” on page
1090 Backup battery
For access, remove these FRUs in order
Table 19. Removal steps of backup battery
ThinkPad X200 Tablet
Step
1100 PCI Express Mini Card for wireless LAN
Full size PCI Express Mini Card
Screw quantity
When installing
vIn models with wireless LAN card that has two antenna connectors, plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable protection tube
Screw quantity
Harf size PCI Express Mini Card
Step
Color
When installing
ThinkPad X200 Tablet
Screw quantity
1110 PCI Express Mini Card for wireless WAN
Step
Color
When installing: When you install the card, plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled AUX
Screw quantity
Note: Step
Step
Color
ThinkPad X200 Tablet
Screw quantity
1130 Bluetooth daughter card BDC-2.1
Step
Color
ThinkPad X200 Tablet
When installing: Make sure that the connector
is attached firmly
Screw quantity
1140 Keyboard bezel
Step
Color
Color
Step
Screw quantity
Torque
In step
Screw quantity
1150 I/O card assembly
Step
Color
Note: The cable is secured with a double-facedadhesive tape
Screw quantity
1160 USB sub card
Step
Color
Table 26. Removal steps of USB sub card continued
Screw quantity
1170 LCD assembly
Step
Color
Screw quantity
Table 27. Removal steps of LCD assembly continued
Step
Color
Table 27. Removal steps of LCD assembly continued
ThinkPad X200 Tablet
Table 27. Removal steps of LCD assembly continued
Screw quantity
For access, remove these FRUs in order
Step
Color
Color
Step
Screw quantity
Torque
Screw quantity
In step
Step
Color
Step
When installing
assembly continued
Screw quantity
Color
Step
Screw quantity
Torque
When installing
from the rubber
1190 System board and ExpressCard slot assembly
Important notices for handling the system board
Bottom
ICH I/O Controller Hub CPU
MCH Memory Controller Hub
Color
Step
Screw quantity
Torque
1200 Base cover and speaker assembly
Applying labels to the base cover
Step
2010 LCD front bezel
Tablet Digitizer Pen model
Screw cap
ThinkPad X200 Tablet
Screw cap
Touch panel and Tablet Digitizer Pen model
Step
Screw quantity
ThinkPad X200 Tablet
2020 Micro-Processorcard
Note: Step
Color
Step
Screw quantity
Torque
Screw quantity
2030 Inverter card
Step
Color
Screw quantity
2040 Hinges
Step
Color
Table 35. Removal steps of hinge continued
2050 LCD panel and LCD cable
Screw cap
Tablet Digitizer Pen model
Step
Screw quantity
4 4 4 4 4 4 4
In step
detach the claws. Then remove the LCD panel
ThinkPad X200 Tablet
without the integrated camera, skip step
When installing Make sure that the connector
Note: Step
is attached firmly
Turn the LCD panel over, and then remove the LCD cable from the LCD panel
Screw quantity
Touch panel and Tablet Digitizer Pen model
Step
Color
Note: Step
ThinkPad X200 Tablet
Page
Screw quantity
2060 Integrated camera
Step
Color
Step
2070 LCD rear cover and wireless antenna cables
Note: Step
Screw quantity
In step
ThinkPad X200 Tablet
Color
Step
Screw quantity
Torque
Wireless WAN antenna, AUX blue
Locations Front view
Rear view
Rear view tablet mode
Bottom view
Rear view ThinkPad X200 UltraBase
UltraBase eject lever Power button security latch
Bottom view ThinkPad X200 UltraBase
Battery charger behind the flip-downdoor
Power button Built-instereo speakers
Optional-serviceCRUs
Parts list
Self-serviceCRUs
Notes
FRU no
Overall
Table 40. Parts list—Overall
RoHS
RoHS
Table 40. Parts list—Overallcontinued
FRU no
Table 40. Parts list—Overallcontinued
42W8049
Table 40. Parts list—Overallcontinued
512-MB DDR3-1066SDRAM SO-DIMM PC3-8500card
Table 40. Parts list-Overallcontinued
Ericsson F3507g Other - Wireless WAN card
Table 40. Parts list—Overallcontinued
42W8011
Table 40. Parts list-Overallcontinued
Battery pack, 8 cell
Table 40. Parts list—Overallcontinued
SATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpm
Table 40. Parts list—Overallcontinued
SATA hard disk drive, 250 GB, 9.5 mm, 5,400 rpm
Table 40. Parts list—Overallcontinued
SATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpm
Table 40. Parts list—Overallcontinued
SATA solid state drive, 64 GB, 8 mm
Table 40. Parts list—Overallcontinued
DVD/CD-RWcombo drive, 9.5 mm
Table 40. Parts list—Overallcontinued
Base cover assembly for
Table 40. Parts list—Overallcontinued
Fan assembly for LV
13 12 11 10 9
LCD FRUs
v“12.1-in.WXGA TFT” on page
1 2 3 4 5 6 b c 8
FRU no
12.1-in.WXGA TFT
Table 41. Parts list—12.1-in.WXGA TFT
RoHS
Table 41. Parts list—12.1-in.WXGA TFT continued
LCD panel, 12.1-in.WXGA for Tablet Digitizer Pen
Table 41. Parts list—12.1-in.WXGA TFT continued
Integrated camera
Table 41. Parts list—12.1-in.WXGA TFT continued
Wireless LAN/WAN antenna assembly
Table 41. Parts list-12.1-in.WXGA TFT continued
Wireless LAN/WAN/USB antenna assembly
Table 41. Parts list—12.1-in.WXGA TFT continued
Inverter card
Language
Keyboard
Table 42. Parts list—Keyboard
RoHS
Miscellaneous parts
Table 43. Parts list—Miscellaneousparts
AC adapters
Table 44. Parts list—ACadapters
Table 46. Parts list—3-pinpower cords
Power cords
Table 45. Parts list—2-pinpower cords
Recovery discs
Windows XP Tablet DVDs
Windows Vista Home Premium 32 bit DVDs
Windows Vista Business 32 bit DVDs
v7453-CTO v2263-CTO v2266-CTO
Windows Vista Business 64 bit DVDs
v4184-CTO v7448-CTO v7449-CTO,EKx v7450-CTO,FYx
v7453-CTO v2263-CTO v2266-CTO
Windows Vista Ultimate 32 bit DVDs
v4184-CTO v7448-CTO v7449-CTO v7450-CTO,8Ax
Tool
Common service tools
Table 52. Parts list—Commonservice tools
1009 Think Place - Building One Morrisville, NC
Notices
Lenovo United States, Inc
U.S.A Attention: Lenovo Director of Licensing
Trademarks
Page
Part Number: 45N3683_01
1P P/N: 45N3683_01