Lochinvar 151-286 operation manual Maintenance Maintenance and annual startup, Service technician

Outdoor Knight Boiler Installation & Operation Manual

9 Maintenance

Maintenance and annual startup

Table 9A Service and Maintenance Schedules

Service technician

(see the following pages for instructions)

	General:
	• Address reported problems
	• Inspect interior; clean and vacuum if
	necessary;
	• Clean condensate trap and fill with fresh
	water
	• Check	for leaks (water, gas, flue,
	condensate)
-UP	• Verify flue and air openings in good
	condition and free of obstruction
	• Check	system water	pressure/system
START
	piping/expansion tank
	• Check control settings
ANNUAL	• Check	ignition and	flame	sense
	electrodes (sand off any deposits; clean
	and reposition)
	• Check wiring and connections
	• Perform start-up		checkout	and
	performance verification per Section 7
	of this manual.
	• Flame inspection (stable, uniform)
	• Flame signal (at least 10 microamps at
	high fire)
	• Clean	the heat exchanger if flue
	temperature is more than 54°F above
	return water temperature.

If combustion or performance indicate need:

•Clean heat exchanger

•Remove and clean burner using compressed air only

•Clean the blower wheel

Owner maintenance

(see the Outdoor Knight User’s Information Manual

for instructions)

	• Check boiler area
	• Check pressure / temperature
Daily	gauge

•Check air and vent termination screens

•Check relief valve

Monthly

• Check condensate drain system

Periodically	• Test low water cutoff (if used)
	• Reset button (low water cutoff)
	• Check boiler piping (gas and
	water) for leaks
Every	• Operate relief valve
6 months

End	• Shut boiler down (unless boiler
of season	used for domestic hot water)
months

49