Table of Contents | 3 |
Introduction |
|
Introduction | 2 |
Important Information | 2 |
Safety Precautions |
|
Safety Precautions | 4 |
Specifications |
|
Heating Specifications | 6 |
Dimensions | 6 |
Electrical Specifications | 6 |
Fuel | 6 |
EPA Compliance | 6 |
Installation |
|
Before you Begin | 7 |
Packing List | 7 |
Installation Options | 7 |
Planning the Installation | 7 |
Stove Placement | 7 |
Floor Protection Requirements | 7 |
Clearances - Straight Installation | 8 |
Clearances - Corner Installation | 8 |
Venting the Pellet Stove | 9 |
Maximum Venting Distance | 9 |
Pellet Vent Type | 10 |
Installing the Pellet Vent | 10 |
Pellet Vent Termination | 10 |
Mobile Home Requirements | 11 |
Outside Air | 11 |
Alcove Installation Requirements | 12 |
Baffle Installation | 12 |
Door Seal Verification | 12 |
Restrictor Adjustment | 12 |
Installation Example: Direct "Through the Wall" | 13 |
Installation Example: Interior Vertical | 14 |
Installation Example: Type A Chimney Retrofit | 15 |
Installation Example: Masonry Fireplace | 16 |
Installation Example: | 17 |
Installation Example: Freestanding Masonry Chim .... | 18 |
Operation |
|
Safety Notice | 19 |
Location of Controls | 19 |
Starting the Heater for the First Time | 19 |
Curing the Paint | 19 |
Priming the Auger | 19 |
Loading Pellets | 20 |
The Two Modes of Operation | 20 |
Operation (continued) |
|
Manual Mode | 21 |
Auto Mode | 22 |
Restrictor Adjustment | 23 |
Adjusting the Fan Speed | 23 |
24 | |
"AUGER ON" Light | 24 |
"FAULT" Light | 24 |
Power Outages | 24 |
Maintenance |
|
Daily Maintenance (whenever using the stove) | 25 |
Inspect the Burn | 25 |
Make Sure Pellets are not Piling Up | 25 |
Check Firepot for Clinkers | 26 |
Cleaning the Firepot | 26 |
Opening the Door | 27 |
28 | |
Clean the Heat Exchange Tubes | 28 |
Vacuum Hopper | 28 |
Clean the Gold Door | 28 |
Clean the Baffles | 29 |
Sweep Ash Into Ashpan | 30 |
Check Ashpan, Dispose if Necessary | 31 |
Clean the Glass | 31 |
Yearly Maintenance (or every two tons) | 32 |
Clean the Exhaust Duct | 32 |
Clean the Exhaust Blower | 33 |
Clean the Vent | 33 |
Door Seal | 34 |
Door Alignment | 34 |
Adjusting the Door Hinge and Latch | 35 |
Check for Air Leaks - Door, Glass and Ashpan .... | 36 |
Replacement Parts | 36 |
Normal Operating Sounds |
|
Normal Operating Sounds | 37 |
Safety Label |
|
Safety Label | 38 |
Warranty |
|
Warranty | 39 |
Optional Equipment |
|
Thermostat | 40 |
Pellet Log | 41 |
Index |
|
Index | 42 |
Travis Industries | 4050418 | 1 0 0 - 0 1 1 5 6 |
