FS3SP Concrete SAW Water System Assy | Multiquip specification

FS3SP CONCRETE SAW — WATER SYSTEM ASSY.

WATER SYSTEM ASSY.

		4
		2
	3/8 DIA. HOSE		5
	16 IN. (41 CM.)		5
	16 IN. (41 CM.)
			6
	CONNECT		3
	WATER SOURCE		3
	WATER SOURCE
	HERE
	1	4

9

10

2

3/8 DIA. HOSE

58 IN. (147.32 CM.)

8

3

7

PAGE 52 — MQ-WHITEMAN FS3SP CONCRETE SAW — PARTS & OPERATION MANUAL — REV. #0 (07/15/02)

Image 52

Multiquip operation manual FS3SP Concrete SAW Water System Assy

Contents

Concrete SAW Page Heres HOW to GET Help Table of Contents Parts Ordering Procedures UPS Ground Service at no charge for freight FS3SP Concrete SAW Safety Message Alert Symbols Seriously injured if you do not follow directions Always wear approved respiratory protection Always wear approved eye and hearing protection Machine Safety Decals FS3SP Concrete SAW Decals General Safety Spilled on a hot engine SAW Transportation Safety Diamond Blade SafetyFS3SP Concrete SAW Rules for Safe Operation FS3SP Concrete SAW Rules for Safe Operation Maintenance SafetyEmergencies FS3SP Concrete SAW Dimensions Description Dimension MM FS3SP Concrete SAW Weights FS3SP Concrete SAW Major Components FS3SP Concrete Saw Basic Components Part Name Not Shown FS3SP Concrete SAW Console Components Operation hours saw has been in useThrough the saw Choke To Change/Clean Air Filter Initial Servicing Engine Oil Dip Stick Engine Oil LimitsEngine Oil Filler and Cap Engine Drain Bolt FS3SP Concrete SAW General Information Power PlantsFamiliarization Blade Guard Assembly Under Carriage SystemBlade Drive System Water System FS3SP Concrete SAW Inspection Before StartingEngine Oil Check Season Do not overfill the battery Additionally, when connecting the positive FS3SP Concrete SAW Inspection -BLADE Rotation downcuts with the turn of the shaftOperating area Poor performance and/or blade damage FS3SP Concrete SAW Inspection -BLADE Placement Diamond Blade Placement Guards and Covers Check B7.5Check the following on the blade flange cover Belts and Covers Belts and Pulleys FS3SP Concrete SAW- Initial START-UP Pull the Choke Knob up into the Open position Push the Start SwitchFigure 23 to start the engine Push the console engine ON/OFF switch to the OFF positionFS3SP Concrete SAW Initial START-UP Stopping the Engine FS3SP Concrete SAW Operation Saw AlignmentWet Saw Operation For wet sawing Factors for sawing economy Finishing a CutDiamond Blades and Blade Speed Blade Speed General Engine Care FS3SP Concrete SAW MaintenanceBearing Lubrication Care AdjustV-Belt Alignment/Replacement Pulleys Complete DriveV-Belts Replacement steps 1 throughGeneral Transmission Care Drive Chainwill Reduce Chain Life Replacement of the Blade Shaft Bearings Blade Shaft Bearing ReplacementRotate the engine down to provide slack in the V-Belts DriveV-Belts Replacement General CleanlinessDriveV-Belt Check Loosen the 4 3/8 HHC screws page 48, itemPage Items Found In the Remarks Column FS3SP SAW Explanation of Code in Remarks ColumnItems Found In the Items Number Column FS3SP Concrete SAW Suggested Spare Parts FS3SP Concrete SAW Troubleshooting Engine Engine Troubleshooting FS3SP Concrete SAW Troubleshooting Engine Sympton Possible Cause Solution FS3SP Concrete SAW Name Plate and Decals FS3SP Concrete SAW Name Plate and Decals FS3SP Concrete SAW Under Carriage Assy WHEEL, 5D X 2W X .625 ID #400 CAP FS3SP Concrete SAW Rear Axle Assy Rear Axle Assy FS3SP Concrete SAW Blade Shaft Assy Part Name QTY Remarks FS3SP Concrete SAW Engine Mount Assy MOUNT, Engine Assy FS3SP Concrete SAW Pointers and Covers Assy FS3SP Concrete SAW Pointers and Covers Assy FS3SP Concrete SAW Water System Assy 15546 15076 FS3SP Concrete SAW Basic Platform Assy Basic Platform Assy SCREW, HHC, Washer 1/4- 20 X 3/4 FS3SP Concrete SAW Blade Mist 20 -INCH Assy GUARD, Blade 20 Assy FS3SP Concrete SAW Manual Raise and Lower Assy FS3SP Concrete SAW Manual Raise and Lower Assy FS3SP Concrete SAW Plug KIT Push Assy Part Name QTY. Remarks FS3SP Concrete SAW Plug KIT Self Proppelled Assy FS3SP Concrete SAW Plug KIT Self Proppelled Assy 10024 NUT, Nyloc 1/4-20 15340 FS3SP Concrete SAW Battery BOX Assy Battery BOX Assy 15203 FS3SP Concrete SAW Battery BOX Assy10024 NUT, Nylock 1/4 0471 FS3SP Concrete SAW Platform Bare Assy 15035 1506915214 15215 Transmission Assy FS3SP Concrete SAW Transmission Assy FS3SP Concrete SAW Transmission Assy SCREW, HHC, Washer 10- 32 X 5/8 CABLE, Throttle 314VTT- 2- 30 1/4 FS3SP Concrete SAW Engine Assy 15729 1510415743 15386 FS3SP Concrete SAW Wiring Diagram Console Side FS3SP Electric Start Wiring Diagram Rocker Switches Terms and Conditions of Sale Parts Page FAX 310