SAFETY INFORMATION
PUMP SAFETY
DANGER
NEVER operate the equipment in an explosive atmosphere or near combustible materials.An explosion or fire could result causing severe bodily harm or even death.
WARNING
Accidental starting can cause severe injury or death. ALWAYS place the ON/OFF switch in the OFF position.
DO NOT place hands or fingers inside pump when pump is running.
NEVER disconnect any emergency or
safety devices. These devices are intended for operator safety. Disconnection of these devices can cause severe injury, bodily harm or even death. Disconnection of any of these devices will void all warranties.
Risk of Electric Shock - This pump has not been investigated for use in swimming pool or marine areas.
CAUTION
DO NOT restrict the fl ow of the discharge hose as it may cause the pump to overheat.
Be careful of discharge hose whipping under pressure.
ALWAYS check pump oil level only when pump is cool. Expansion due to heat may cause hot oil to spray from the oil plug when the oil plug is removed. The possibility of severe scalding may exist.
NOTICE
ALWAYS place the pump in an upright position on a platform before using.The platform will prevent the pump from burrowing itself on soft sand or mud.
NEVER operate pump on its side.
DO NOT allow the pump to freeze in water.
NEVER leave an open pump chamber unattended.
ALWAYS keep the machine in proper running condition.
DO NOT attempt to thaw out a frozen pump by using
a torch or other source of fl ame. Application of heat in this manner may heat the oil in the seal cavity above the critical point, causing pump damage.
DO NOT pump water with a temperature greater than 104°F.
DO NOT pump liquids containing acid or alkali.
ALWAYS check strainer before pumping. Make sure strainer is not clogged. Remove any large objects, dirt or debris from the strainer to prevent clogging.
ALWAYS use a large basket strainer when pumping water that contains large debris.
ALWAYS fl ush pump (clean) after use when pumping water concentrated with heavy debris. It is very important to always fl ush the pump before turning it off to prevent clogging.
Fix damage to machine and replace any broken parts immediately.
ALWAYS store equipment properly when it is not being used. Equipment should be stored in a clean, dry location out of the reach of children and unauthorized personnel.
NEVER lubricate components or attempt service on a running machine.
NEVER run pump dry.
ALWAYS allow the machine a proper amount of time to cool before servicing.
Keep machine in proper running condition.
ELECTRICAL SAFETY
DANGER
The electrical voltage required to operate pump can cause severe injury or even death through physical contact with live circuits. ALWAYS disconnect electrical power from pump before performing maintenance on pump.
WARNING
To reduce the risk of electric shock, connect only to a circuit protected by a
PAGE 6 — ST4125G/ST6125G SUBMERSIBLE PUMP • OPERATION MANUAL — REV. #0 (11/18/10)