Napoleon Fireplaces GT8P, GT8N TABLE of CONTENTS, Please Retain This Manual For Future Reference

2

TABLE of CONTENTS

PG 2-5	INTRODUCTION	10	FINISHING
	Warranty		Door Removal
	Dimensions		Glass Removal
	General Instructions		Frame Installation
	General Information		Light Installation
	Care of Glass & Plated Parts	11	OPERATING INSTRUCTIONS
5-6	VENTING
		12	MAINTENANCE
	Venting Lengths
			Gas Pressure Adjustment
	Air Terminal Locations
			Venturi Adjustment
7-9	INSTALLATION/FRAMING
		13	REPLACEMENTS
	Wall & Ceiling Protection
			Replacement Parts
	Using Flexible Vent Components
			Flexible Vent Kits
	Horizontal Air Terminal Installation
			Terminal Kits
	Fireplace Vent Connection
			Accessories
	Gas Installation
		14	TROUBLE SHOOTING GUIDE
	Framing
	Nailing Tab Installation	15	FIREPLACE SERVICE HISTORY
	Clearance to Combustibles
		16	NOTES
9	ELECTRICAL CONNECTION

Hard Wiring Connections

PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE

This appliance may be installed as an OEM installation in a manufactured home (USA only) or mobile home and must be installed in accordance with the manufacturers instructions and the Manufactured Home Construction and Safety Standard, Title 24 CFR, Part 3280 in the United States or in the Mobile Home Standard, CAN/CSA Z240 MH, Series in Canada.

This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.

This appliance may be installed in an aftermarket, permanently located, manufactured home (USA only) or mobile home, where not prohibited by local codes.

This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.

WARNING

•Do not burn wood or other materials in this fireplace.

•Adults and especially children should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or clothing ignition. Supervise young children when they are in the same room as the fireplace.

•Clothing or other flammable material should not be placed on or near the fireplace.

•Due to high temperatures, the fireplace should be located out of traffic and away from furniture and draperies.

•Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot surfaces.

•Even after the fireplace is out, the glass and/or screen will remain hot for an extended period of time.

•Check with your local hearth specialty dealer for safety screens and hearth guards to protect children from hot surfaces. These screens and guards must be fastened to the floor.

•Any safety screen or guard removed for servicing must be replaced prior to operating the fireplace.

•It is imperative that the control compartment and burner in the fireplace and venting system are kept clean. The fireplace and its venting system should be inspected before use and at least annually by a qualified service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. The fireplace area must be kept clear and free from combustible materials, gasoline and other flammable vapours and liquids.

•Under no circumstances should this fireplace be modified.

•This fireplace must not be connected to a chimney flue pipe serving a separate solid fuel burning appliance.

•Do not use this fireplace if any part has been under water. Immediately call a qualified service technician to inspect the fireplace and to replace any part of the control system and any gas control which has been under water.

•Do not operate the fireplace with the glass door removed, cracked or broken. Replacement of the glass should be done by a licensed or qualified service person.

•Do not strike or slam shut the fireplace glass door.

•The glass door must be kept closed while the fireplace is operating to prevent exhaust fumes containing carbon monoxide, from entering into the home. Temperatures of the exhaust escaping through this opening can also cause the surrounding combustible materials to overheat and catch fire.

•Only doors / optional fronts certified with the unit are to be installed on the appliance.

W415-0619 / A /08.09.07 NOTE: Changes, other than editorial, are denoted by a line in the margin.