Installation Fundamentals
building codes, some municipalities |
| Installation of |
plenum rated wire (check your local | Figure 11 |
|
| Brackets, Frames | |
require conduit). |
| |
|
| |
In traditional wood stud/drywall construc- |
| and Grilles in New |
tion you can cut the hole for the speaker |
| |
|
| |
and utilize the large hole to auger holes |
| Construction |
across, up or down the wall for as far as |
| |
|
| |
your drill bit will take you. If you have |
|
|
matching paint and take reasonable care in |
| Stage One: Before Drywall is Hung |
patching you can cut a hatch in the dry- |
| |
| Insulating the Wall Cavity. | |
wall at each stud, run your wire, and patch |
| |
| If feasible, fill the wall cavity with insula- | |
and |
| |
| tion at this point. | |
|
|
When you are dealing with the unknown
Attach the wings to the bracket by snap-
because of the structure of your home, or
Screw one side of the assembled bracket with wings to the stud using one of the supplied screws. Level the bracket. Screw the other side of the bracket to the stud. Two screws on each side makes for a very secure installation. Attach the wire to the bracket at the indicated wire tie points (See Figure 14).
Stage Two: Before PaintScrew the frame to the installed bracket using the supplied screws. Do not over- tighten the screws. This will distort the frame and the grilles will not fit (this is not permanent, just loosen the screws and the
Installation of Brackets, Frames
with difficult to patch wall materials like
ping them into the sides of the bracket. The wings can be shortened by breaking
grille will pop in) (See Figure 15).
plaster, lath and plaster, faux finishes,
wallpaper etc., be patient. A careful study
them along the scored lines if their length
of the potential problems before you start
will interfere with a corner or eaves. You
the job will pay off.
can mount the bracket horizontally or ver-
tically (See Figure 13).Painting the Aluminum Grilles
The grille is important to the sound of the HD loudspeakers. Do not fill the holes of the grille with paint.
Figure 12
and Grilles in New Construction
Figure 13
13 |
|
|
| 14 | |
|
|
|