S t e a m e r 6 2 5 - A
Cleaning - Daily PM Tasks
WARNING
Turn the unit off and unplug the power cord from the electrical recep- tacle. Proceed with caution, unit is still hot!
CAUTION
This unit is not watertight. Do not clean with a water jet/jet spray. Do not immerse the unit in water.
Do not use abrasive materials such as scrapers, steel wool, etc. to clean the spatula or steam chamber.
While wearing protective gloves, remove the top cover by
1 pulling up and off the unit.
Top Cover
The following equipment is required:
•Detergent or Cleaner
•Delimer/Lime Scale Remover (as required)
•Sanitizer
•Clean sanitized towel
•Protective (insulated) gloves
2 While wearing protective gloves:
A.Remove spatula.
B.Remove the top plate by carefully sliding it forward
and out of the unit.
C.Remove the venturi
plate.
Top Plate
Spatula
Venturi Plate
A.Wash top cover, top plate, and venturi plate in a solution of
3 detergent and water.
B.Rinse with clean water, and then sanitize in a solution of sanitizer.
C.Let air dry.
5 | Wash all external surfaces of the steamer with a solution of |
detergent and water. Using the solution in a spray bottle, |
spray directly onto a clean sanitized towel and wipe the unit clean.
CAUTION
Do not spray directly on the unit or use abrasive cleaners!
4 Wipe the steam chamber surface with a clean sanitized cloth.
OPTIONAL: If the surface shows signs of excessive calcium and lime buildup, dissolve two tea- spoons of delimer in a
small coffee cup with 100mI of water. Pour half on each side. Using a clean sanitized towel, wipe the internal surfaces of the steam chamber. Allow to sit for 5 minutes. Using a clean sani- tized towel,thoroughly rinse and wipe, the internal surfaces of the steam chamber.
6 | Reassemble the unit. |
Turn the unit on. When unit is preheated, run a minimum of |
four cycles to prime the unit and remove any residual cleaner.
It is recommended that the steamers go through a deliming procedure at least once a month. Some hard water areas may require increased deliming based upon actual buildup.
Steamer | 6 | Printed in USA 0910 © 2003 |