Manuals / QHT / Household Appliance / Boiler

QHT Boiler manual Thermostat, Note Power failure reference page

Models: Boiler

1 40

Download 40 pages 34.95 Kb

Page 25

Note: Power failure reference page 9.

Note: Power failure reference page 9.

Thermostat

NOTE: All wiring must be done in accordance with applicable state, local and national codes. Use only copper conductors.

3Wood installed in combination with a oil/gas boiler

Note: The operation of the gas boiler must be verified for acceptable operation before and after installation of the add-on appliance by a gas fitter who is recognized by the regulatory authority.

PIPING NOTES:

CAUTION

1.This drawing is meant to show system piping concept only.

2.The installer is responsible for all equipment & detailing required by local codes.

3.Discharge of Pressure Relief Valve must be piped without valves to within 3” of the floor.

4.Where required, Low Water Cutoff must be installed in the Supply piping of the oil/gas boiler.

5.DO NOT interfere with the normal delivery of heated water from the original boiler to the system.

6.Make sure that excessive pressure will not be developed in any portion of the boiler or system through properly sizing the expansion tank.

25

Image 25

QHT Boiler manual Thermostat, Note Power failure reference page

Contents

SAVE THESE INSTRUCTIONS 3Wood Cast Iron BoilerFor wood and soft coal only Boiler Serial NoDear Customer Table of Contents DANGER IMPORTANT INFORMATIONPlease read this page carefully Codes and RegulationsNOTE: Inspect and clean chimney flue regularly WARNING SAFETY RULESDANGER WARNING – RISK OF FIREIDENTIFICATION WARNING -CanadianExploded view of top bushing arrangement PROCEDURE IN EVENT OF POWER FAILUREAdjusting the Flue Gas Damper REFUELING THE BOILERThe draft regulator should be adjusted as follows Reloading WoodOverview WOOD BURNINGSelecting Your Wood Cutting and Drying Your Own WoodAvailable Heat Per Cord In Millions of BTU/ HR The Heat Value of WoodWOOD STORAGE The temperature in the stack may be controlled by CREOSOTE∙Close flue gas damper ∙Turn knob on draft regulator to 40CChimneys Chimney CleaningChimney Construction DowndraftsDANGER COAL FIRECOAL FIRES CAN PRODUCE POISONOUS GASES BURN BITUMINOUS SOFT COAL ONLYTechnology with 3 Pass The 3WOOD Design3Wood Installation considerationsLAYOUT OF THE MAIN COMPONENTS Transporting Recommended Minimum ClearancesSOURCES OF COMBUSTION AIR ARE NO GALVANIZED PIPEFLUE GAS OUTLET COMBUSTION AIR INTAKEASSEMBLING THE CASING Installation of Controls Installation of Flue Gas Partition Installation of Draft RegulatorChain must be exactly 32 inches long STARTING AND MAINTAING A WOOD FIRE Commissioning the 3WOOD BoilerNote: Never detach the chain from the rods or the handle3WOOD boiler piping and wiring Considerations Thermostat Note Power failure reference page∙Fuel savings of 20% 4 Way Mixing Valve Piping NOTE All wiring must be done in accordance with applicable state, local and national codes. Use only copper conductors boiler Parallel Piping NOTE: All wiring must be done in accordance with applicable state, local and national codes. Use only copper conductors Page Description Description Page Routine Cleaning Maintenance∙Use suitable safety equipment SHUTDOWNTroubleshooting System Checkout Cast-IronWater Boilers Warranty for BIASI - 3WOOD ResidentialBIASI BOILER WARRANTY REGISTRATION QHT Inc 3560 Lafayette Rd Portsmouth, NHQHT Inc 3560 Lafayette RD Portsmouth, NH For service please contactTelephone 800-501-7697Fax 3 WOOD Boiler Manufactured by