Razor E175, E100, E125, E150 owner manual Repair And Maintenance, Left Side Brake, Frame, Middle

REPAIR AND MAINTENANCE

Note: Rear wheel hardware sequence

18-1 18-718-2

18-3 18-4

4Remove wheel and install replacement wheel.

(Note the sequence of the hardware)

7 Re-attach the chain guard.

5 Push the chain tensioner down to install the chain on both sprockets.

6 With two 13 mm open wrenches, re-tighten the locknuts.

18-8

18-4 18-3 18-2

18-7

18-1

Left Side (Brake)

18-1 13 mm Locknut

18-7 Spring Washer

18-2 Washer

Frame

18-3 Washer (Plate Cut)

18-4 Spacer (Long)

Middle

18-8 Rear Axle Bolt

REPAIR AND MAINTENANCE

qBattery Care and Disposal

Do not store in freezing or below freezing temperatures. To properly maintain your battery and ensure maximum battery life, carefully read the “Charging the Battery” section on page 3 of this owner’s manual.

CONTAINS SEALED LEAD ACID BATTERIES. BATTERIES MUST BE RECYCLED.

Disposal: Your Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an environmentally safe manner. Do not dispose of a lead-acid battery in a fire. The battery may explode or leak.

Do not dispose of a lead-acid battery in your regular household trash. The incineration, land filling or mixing of sealed lead-acid batteries with household trash is prohibited by law in most areas. Return exhausted batteries to a federal or state approved lead-acid battery recycler or a local seller of automotive batteries. If you live in Florida or Minnesota, it is prohibited by law to throw away lead-acid batteries in the municipal waste stream.

qCharger

The charger supplied with the electric scooter should be regularly examined for damage to the cord, plug, enclosure and other parts. In the event of such damage, the product must not be charged until it has been repaired or replaced.

Use ONLY the charger supplied with this product or a replacement specified by Razor.

qWheels

Wheels and drive system are subject to normal wear and tear. It is the responsibility of the user to periodically inspect wheels for excess wear, and to adjust and replace drive train components as required.

qReplacement Parts

For the complete selection of replacement parts visit www.razor.com.

qRepair Centers

For a list of authorized Razor repair centers:

•Check online at www.razor.com.

•Call 866-467-2967 for the center nearest you.

Right Side (Throttle) 18-1 13 mm Locknut 18-7 Spring Washer 18-2 Washer

Frame

18-3 Washer (Plate Cut)

18-4 Spacer (Short)

WARNING: If a battery leak develops, avoid any contact with leaking acid and place the damaged battery in a plastic bag. Refer to the disposal instructions at left. If acid comes into contact with skin or eyes, flush with cool water for at least 15 minutes and contact a physician.

WARNING: Battery posts, terminals and related accessories contain lead and lead compounds. Wash your hands after handling.

Need Help? Visit our website for replacement parts, product support and a list of authorized service centers at www.razor.com or call toll free 866-467-2967 Monday - Friday 8AM - 5PM Pacific Time. Please have the product I.D. code located on the white label on your product or back of charger available for better assistance.

6