Roberts Gorden CTU 22 TO 115 Fire Hazard, close to heater, injury or property damage

SECTION 16: REMOVAL AND REPLACEMENT PARTS

Attach this information to the wall near the ROBERTS GORDON® heater

®

Read the Installation, Commissioning, Operation and Service Manual thoroughly before installation, operation or service.

OPERATING INSTRUCTIONS WARNING

1.STOP! Read all safety instructions on this information sheet.

2.Open the manual gas valve in the heater supply line.

3.Turn on electric power to the heater.

4.Set the thermostat to desired setting (above ambient temperature). The automatic starting sequence begins.

NOTE: Following long shutdown periods, the burner control may go to to 'LOCKOUT' during the start sequence. Push the reset button to recommence firing. Contact service department if 'LOCKOUT' continues (see manual for details).

TO TURN OFF THE HEATER

1. Turn the thermostat/time switch to 'OFF'. The burner will turn 'OFF'					Fire Hazard
immediately, but fans will continue to cool heat exchanger until the fan
thermostat switches off.				Some objects can catch fire or explode when placed
IF THE HEATER WILL NOT OPERATE, TO ENSURE YOUR SAFETY,				close to heater.
FOLLOW THESE INSTRUCTIONS TO SHUT DOWN YOUR HEATER				Keep all flammable objects, liquids and vapors the
1. Set the thermostat to off or the lowest setting.				required clearances to combustibles away from heater.
2. Turn off electric power to the heater.				Failure to follow these instructions can result in death,
3. Turn off the manual gas valve in the heater supply line.
4. Call your registered installer/contractor qualified in the installation				injury or property damage.
and service of gas-fired heating equipment.
Installation Clearances
	Roof Terminal			Clearances to Combustibles
Air
Intake			15 cm		15 cm
		Flue	3 m	50 cm	50 cm**
Wall
		60 cm
Terminal
					30 cm
			2.5 - 3.5 m*
				**80 cm is necessary to service heater.
*Heaters may be mounted at a higher level if destratification
fans and/or turn down nozzles are installed.
Roberts-Gordon Europe Limited			Fax: +44(0)121 506 7701	Roberts-Gordon, LLC	Telephone: 716.852.4400
Unit A, Kings Hill Business Park			Service Telephone: +44(0)121 506 7709	1250 William Street	Fax: 716.852.0854
Darlaston Road, Wednesbury			Service Fax: +44(0)121 506 7702	P.O. Box 44	Toll Free: 800.828.7450
West Midlands WS10 7SH UK			E-mail: uksales@rg-inc.com	Buffalo, NY 14240-0044 USA
Telephone: +44(0)121 506 7700			E-mail: export@rg-inc.com

Installation Code and Annual Inspections:

All installations and service of ROBERTS GORDON® equipment must be performed by a contractor qualified in the installation and service of equipment sold and supplied by Roberts-Gordon and conform to all requirements set forth in the ROBERTS GORDON® manuals and all applicable governmental authorities pertaining to the installation, service and operation of the equipment. To help facilitate optimum performance and safety, Roberts-Gordon recommends that a qualified contractor annually inspect your ROBERTS GORDON® equipment and perform service where necessary, using only replacement parts sold and supplied by Roberts-Gordon.

For installations at elevations above 2000' (610 m), the appliance shall be derated 4% for each 1000' (305 m) of elevation above sea level.

Further Information:Applications, engineering and detailed guidance on systems design, installation and equipment performance is available through ROBERTS GORDON® representatives. Please contact us for any further information you may require, including the Installation, Commissioning, Operation and Service Manual.

These products are not for residential use.

© 2007 Roberts-Gordon, LLC www.rg-inc.com Printed in U.S.A. P/N 91040028 Rev B

45