TROUBLESHOOTING
PROBLEM | CAUSE | CORRECTION | |||
Pump hasfollowingp_oblems: | 1. | Nozzle in low pressure mode, | 1,, Pull nozzle backwardfor high | ||
failure to pn_uce pressure,erratic |
|
|
| pressuremode. | |
pressure,chattering,loss of pressure, | 2_ Low regulator pressure | 2_ Adjustrogutatortodesiredsetting, | |||
lowwater volume. | 3. | Water inlet is blocked. | 3. | Clear inlet | |
| 4o | Inadequate water supply | 4. | Provideadequate waterflow. | |
| 5o inlet hose is kinked or leaking | 5o | Straighteninlethose,patch leak. | ||
| 6. | Clogged inlet hose strainer. | 6o | Check and clean Inlet hose strainer. | |
| 7_ | Detergent line is not submerged. | 7. | Submergedetergent line. | |
| 8. | Water supply is over t40°F. | 8. | Providecoolerwater supply. | |
| 9_ | Outlet hose is blocked or leaks. | 9. | Clear blocks inoutlethose_ | |
| 10, | Gun leaks., | 10 | Replace gun. | |
| 11_ | Nozzle is obstructed. | 11_ | Clear _], | |
| 12. | Pump isfaulty° | 12, | ContactSears ServiceDepartment, | |
Detergentfails to mix with spray, | 1. | Detergentline Is not submerged. | 1. | Insert | chemical line into detergent,. |
| 2. | Chemical filter is clogged | 2, | Clean | or replace filter/deteq;tent line. |
| 3. | Nozzle is in highpressuremode | & | Push | nozzle forward for |
|
|
|
| low pressure mode, | |
Engine runs good at | Enginespeed is too slowo | Contact Sears Service DepadrnenL |
Enginewillnot start;or starts | 1. | Low oil level |
| 1. | Fill crankcase to proper level. |
| |||||
and runsrough | 2. | Dirty air cleaner |
| 2, | Clean | or replace air cleaner. |
| ||||
| 3. | Out | of gasoline. |
| 3. | Fill fuel | tank. |
|
| ||
| 4. | Stale | gasoline,, |
| 4, | Drain | gas tank; fill with | fresh | fuel. | ||
| 5,_ Spark | plug wire | not connected | 5. | Connect | wire to spark | plug. |
| |||
|
| to spark plug |
|
|
|
|
|
|
| ||
| 6_ | Bad spark plug. |
| 6,, | Replace | spark plug. |
|
| |||
| 7,, | Water | in gasotine_ | 7,, | Drain | gas tank; fill with | fresh | fuel. | |||
| 80vemhoking |
| 8 | Open | choke full'>,and crank engine_ | ||||||
| 9 | Excessively rich fuel mixture. | 9 | Contact | Sears Service | Department. | |||||
| 10o | Intake valve stuck open or closed. | 10o | Contact Sears Service | Department, | ||||||
| 11o | Engine has lost | compression. | 11. | Contact Sears Service | Department, | |||||
Engine shuts down during operation | 1, | Out | of gasoline,, |
| 1. | Fill fuel tank. |
|
| |||
| 2. | Low | oil level,. |
| 2o | Fill crankcase to properlevel. |
Engine lacks power,_ | Dirty air filter. | Replace air filter, |
Engine "hunts" or falters. | Choke is openedtoo soon., | Move choke to halfway posffion |
|
| until engine runs smoolhly_ |
18