PROBLEM
Pump has following problems:
failure to produce pressure, erratic
pressure, chattering, loss of
pressure, low water volume.
Detergent fails to mix with.
spray.
Engine runs good at
but "bogs down" when toad is added
Engine willnot start;or starts
and runs rough
CAUSE
"k Nozzle in low pressure mode,
2.Water inlet is blocked.
3.Inadequate water supply
4.Inlet hose is kinked or leaking
5.Clogged inlet hose strainer.
6.Water supply is over 140'F.
7.Outlet hose is blocked.
8.Outlet hose leaks.
9.Gun leaks.
10.Nozzle is obstructed.
11.Pump is faulty.
1.Detergent line is not submerged.
2.Chemical filter is clogged.
3.Nozzte is in high pressure mode.
Engine speed _stoo slow.
1.Dirty air cleaner
2.Out of gasoline.
3.Stale gasoline.
4.Spark plug wire not connected to spark ptug
5.Bad spark plug.
6.Water in gasoline.
7.Overchoking.
8.Excessively rich fuet mixture.
9.Intake valve stuck open or closed.
10.Engine has lost compression.
CORRECTION
t.Putl nozzle backward for high
pressure mode.
2.Clear inlet
3.Provide adequate water flow_
4.Straighten inlet hose, patch leak.
5.Check / clean inlet hose strainer.
6.Provide cooler water suppiy.
7.Clear blocks in outlet hose.
8.Replace outlet hose if leaking.
9.Replace gun.
10.Clear nozzle.
11.Contact Sears Service Department.
1.Insert chemical tine into detergent.
2.Clean or replace filter/detergent line.
3.Push nozzleforwardfor low pressure mode.
Contact Sears Service Department.
t.Clean or replace air cleaner.
2. FIll fuel tank. |
|
| ||
3. Drain gas tank; fil! with fresh fuel. | ||||
4. | Connect | wire | to spark ptug. | |
5. | Replace | spark | plug. |
|
6. | Drain gas tank; filf with fresh fuel. | |||
7. | Set engine throttle control lever to | |||
| fast position. |
|
| |
8. | Contact | Sears | Service | Department. |
9. | Contact | Sears | Service | Department. |
I0. | Contact | Sears | Service | Department. |
Engine | shuts | down during | 1. Out of gasoline. |
operation |
|
| |
Engine | lacks | power. | Dirty air filter. |
1. | FIII fuel tank. |
Replace air fitter.
15
