Manuals / Ski-Doo / Marine Equipment / Jet Ski

Ski-Doo GTI Series manual Fuel Tank, Engine Compartment, Steering System and Side Vanes O.P.A.S

Models: RXT Series WAKE Series GTX Series GTI Series RXP Series

1 148

Download 148 pages 59.28 Kb

Page 37

1

F19H02Y

TYPICAL

1. Battery

Fuel Tank

With the watercraft horizontal, fill the fuel tank to specified level.

Check fuel tank retaining straps/ fasteners.

Engine Compartment

WARNING

Should any leak or gasoline odor be present, do not start the engine. Refer to an authorized Sea-Doo dealer before use.

PRE-RIDE INSPECTION

WARNING

When operating the engine while the watercraft is out of the water, the heat exchanger in the ride plate may become very hot. Avoid any contact with ride plate as burns may occur.

Steering System and Side Vanes (O.P.A.S.)

Assisted by another person, check steering operation for free movement. When the handlebar is horizontal, the jet pump nozzle should be in the straight ahead position. The rear edge of side vanes should be pointing out- side of watercraft by approximately 20°. Ensure the jet pump nozzle and side vanes pivot easily and in the same direction as the handlebar.

WARNING

Check handlebar and correspond- ing steering nozzle operation be- fore starting. Never turn handle- bar while someone is nearby rear of watercraft. Keep away from steering moving parts (nozzle, side vanes, linkage etc.).

Engine Oil

Ensure oil level is appropriate as speci- fied in MAINTENANCE PROCEDURES section. Check for oil leaks on engine and in engine compartment.

Throttle System

Check throttle lever for free and smooth operation. It should return to its initial position immediately after it is released.

Engine Coolant

Ensure coolant level is appropriate as specified in MAINTENANCE PROCE- DURES section. Check for coolant leaks on engine, in bilge and from ride plate.

WARNING

Check throttle lever operation be- fore starting the engine.

Shifter System

Check reverse gate operation for free movement. With shift lever in forward position, the gate should be in upward position; and offering a resistance to go downward. With the shift lever in neutral position, gate should be in mid-

SAFETY INFORMATION 35

Image 37

Ski-Doo GTI Series Fuel Tank, Engine Compartment, Steering System and Side Vanes O.P.A.S, Engine Oil, Throttle System

Contents

2009 California Proposition 65 Warning Know Before You Go Safety MessagesAbout this Operators Guide Foreword Table of Contents Vehicle Information PRE-RIDE Inspection cont’dSpecifications Special Procedures cont’dIdentification Numbers Engine Emissions InformationTable of Contents Safety Information Safety InformationAvoid Carbon Monoxide Poisoning General PrecautionsAvoid Gasoline Fires and Other Hazards Avoid Burns from Hot PartsReminders Regarding Operation Special Safety MessagesBefore Getting Underway Operators and Passengers Water Sports Swim Area Buoy CUT Motor Stop Skier OK Pick ME UP Safe Boating Courses HypothermiaRequired Safety Equipment Safety EquipmentPersonal Flotation Devices PFDs Type I Wearable Helmets Additional Recommended EquipmentDrugs and Alcohol Safe Boating PracticesSafe Operation Manoeuvrability Watercraft/Towing Operator/Passenger AwarenessSafety Information Crossing Operating RulesMeeting Head-On Navigation SystemCollision Avoidance Fueling Procedure Fueling ProcedureRecommended Fuel Wake Models TraileringLaunching/Loading Location of the Important Labels Label 1 Typical GTX, Wake and RXT Models Label 1 Typical RXP Models Label 1 GTI Models Label 7 Typical Not shown Label Wake ModelsWatercraft Outside North America Operation PRE-RIDE InspectionHull BatteryJet Pump Water Intake BilgeEngine Compartment Fuel TankSteering System and Side Vanes O.P.A.S Engine OilBallast Tanks Variable Trim System VTSStorage Compartment Covers and Seat Wakeboard RackVehicle Information 14614,17 CONTROLS/INSTRUMENTS/EQUIPMENTSTypical X Package Models Typical GTX Limited Dess Post Engine Stop Switch Digitally Encoded Security System Dess HandlebarLimited-Speed Operation Engine Start/Stop Button Throttle LeverRXP, RXP-X, RXT-X and Wake Models RXP-X, RXT-X and Wake Models High Performance VTSInformation Center Gauge Shift LeverOptional on GTI 130 Model SpeedometerTachometer Fuel LevelAll Models Except GTI Models Indicator LightsGTI SE 130 Model Water Depth DisplayAll Models Except GTI Glove BoxRXP 215, RXP-X, RXT-X and Wake Models GTI ModelsGPS Receiver Global Positioning System Front Storage Compartment GTI, GTX and Wake Models Self-Contained Removable Storage BinGTX, Wake and RXT Models Auxiliary Storage CompartmentsRemovable Tray GTX Limited and Wake ModelsGTX and Wake Models Rear Seat LatchRXT Models RXP ModelsEngine Compartment Seat LatchFront and Rear bow/stern Eyelets Rear Storage BasketGTX, Wake, RXT Models Except X Package Front bow EyeletBoarding Step Mooring CleatsBilge Drain Plugs All Models Except GTI 130 and RXP ModelsSKI/WAKEBOARD Post Lifted Tighten the straps by firmly pulling upwards Fin outward Ballast System Recessed Cargo CleatsTypical Ballast System InstallationTo Fill Removal To EmptyPrinciple of Operation Operating InstructionsPropulsion Neutral and Reverse Variable Trim System Steering Models with Sliding Side Vanes O.P.A.S. System Off-Power Assisted Steering System O.P.A.SGeneral Boarding the WatercraftBoarding from a Dock or in Shallow Water Boarding in Deep Water Cold and Warm Engine RidingAir Intake Opening Rear Grab HandleRough Water or Poor Visibility Operation Operation with Wakeboard Rack and Ballast TanksCrossing Waves Stopping/DockingPost-Operation Care Shutting Off the EngineGeneral Care Additional Care for Foul Water or Salt WaterExhaust System Flushing Ballast System Anticorrosion TreatmentJet Pump Water Intake and Impeller Cleaning Special ProceduresIn-Water Cleaning On-Beach Water CleaningSubmerged Watercraft Capsized WatercraftWater-Flooded Engine Towing the Watercraft in WaterSupply hose with red tape Maintenance Information Maintenance Schedule PART/TASK Electrical System First 10 Hours Hour Inspection Recommended Engine Oil Maintenance ProceduresEngine Oil Level Recommended Engine Coolant Engine Oil Change and Oil Filter ReplacementEngine Coolant Level Throttle Body Engine Coolant ReplacementThrottle Body Lubrication Fuses Throttle CableThrottle Cable Inspection Throttle Cable LubricationFuse Description Location Fuse Location/DescriptionBody and Hull Ride Plate and Water Intake GrateSki/Wakeboard Post if so equipped Storage Storage and Preseason PreparationModels X Packages Exhaust System Protection Engine Internal Lubrication Bilge Cleaning Battery Removal and ChargingEngine Coolant Test Ballast System Removal and FlushingPreseason Preparation Storage and Preseason Preparation Technical Information Identification Numbers 100Engine Engine Emissions Information 101Manufacturers Responsibility Dealers Responsibility102 SpecificationsLoading Capacity 103Vehicle RXT Models 104105 Vehicle 106107 Vehicle GTX Models 108109 Vehicle GTI Models 110Cooling system Coolant type 111112 113 TroubleshootingTechnical Guidelines 114115 116 117 Monitoring System 118Pilot Lamps and Message Display Information Beeper Code Information 119See Engine Overheating 120121 WarrantyScope 122123 Warranty Coverage Duration124 Conditions to have Warranty CoverageTransfer 125126 Manufacturer’s Limited Warranty Coverage Your Emission Control Warranty Rights and Obligations127 Three Stars Ultra Low Emission128 129 Owner’s Warranty Responsibilities130 131 132 Bombardier Recreational Products INC 133134 Scope of the Limited Warranty135 Warranty Coverage Period136 137 Privacy INFORMATION/DISCLAIMER 138Canada USAChange of ADDRESS/OWNERSHIP 139140 NEW Address or NEW Owner 141142 143 144 Hull Fait AU / Made in Canada