DANGER
•NEVER store a spare cylinder under or near the appliance or in an enclosed area.
•Never fill a cylinder beyond 80% full.
•An overfilled or improperly stored cyclinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death.
•If you see, smell or hear gas escaping, immediately get away from the LP cylinder/appliance and call your fire department.
CAUTION
If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.
Match Lighting
1.Attach match to match lighting stick, light match.
2.Insert lit match through grate and next to burner. Turn gas on for appropriate burner. Repeat for other burner.
Safety Tips
The use of alcohol, prescription or nonprescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.
When grill is not in use, disconnect 1 lb. cylinder.
Never move grill while in operation or still hot. Allow the appliance to cool before moving or storing.
Use only tools supplied or plastic tools.
Maximum load for side shelves is 10 lbs.
The regulator may make a humming or whistling noise | Match |
during operation. This will not affect safety or use of grill. | lighting |
If you have a grill problem see the Troubleshooting Section.
Light burners. Check to make sure they are lit, close the lid and warm up grill on high for 20 minutes. Curing of paint and parts will produce an odor only on first lighting.
Grill is not to be used as a heater.
stick
Ignitor Lighting
Do not lean over grill while lighting.
1.Open lid during lighting. Make sure LP cylinder is properly connected to regulator.
2.Turn LEFT knob to 
.
3.Turn rotary ignitor knob
(up to 5 times) to light. Be sure burner lights and stays lit.
4.If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.
5.To ignite RIGHT burner, turn right knob to 
and repeat steps
6.If IGNITOR does not work, follow match lighting instructions.
Before Your First Cookout.
Leak test your grill L.ight burners, check to make sure they are lit, close the lid and warm up grill on HIGH for 10 minutes. Curing of paint and parts will produce an odor only on first lighting.
Turning Grill Off
•Turn knobs to OFF position. Make sure knobs pop up. If it does not, discontinue use and order new part.
•Disconnect 1 lb. Cylinder.
WARNING |
Turn controls OFF and disconnect cylinder when not |
in use. |
Hose Check
•Before each use, check to see if hoses are cut, worn or kinked. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer.
NormalKinked
HoseHose
06401314 • 5
