Manuals / Xantrex Technology / Computer Equipment / Power Supply

Xantrex Technology 400R manual Obtaining a Replacement Battery

Models: 400R

1 74

Download 74 pages 51.97 Kb

Page 51

Obtaining a Replacement Battery

Replacing the Internal Battery

CAUTION

Discharging the internal battery below 10.0 V will damage the battery and shorten its life.

Obtaining a Replacement Battery

Replacement batteries are available from stores that specialize in and have a selection of lead acid, AGM (Absorbed Glass Mat) batteries.

Refer to Table 4-1 for a listing of batteries approved for use with the XPower Powerpack:

Table 4-1Approved Replacement Batteries

Replacement Battery	Where to Buy

Panasonic	Panasonic:
#LC–X1220P	Tel: 1-800-833-9626
(12 V 20 Ah)	web: www.pasc.panasonic.com

	Digi-Key
	Tel: 1-800-344-4539

EnerSys	EnerSys
#NPX–80	Tel: 1-800-962-1287 (Eastern US)
(12 V 20 Ah)	Tel: 1-800-423-4667 (Western US)

	web: www.EnersysStationary.com

Replacing the Battery

WARNING: Shock or electrical hazard

Read this entire section before disassembling the unit.

Before attempting to replace the internal battery, make sure you:

•Disconnect any charging cables, 12 V DC appliances, and AC appliances from the XPower Powerpack.

975-0162-01-01

4-7

Image 51

Xantrex Technology 400R manual Obtaining a Replacement Battery, Replacing the Battery WARNING Shock or electrical hazard

Contents

Owners Guide XPower Powerpack 400 PLUS and 400RDisclaimer About XantrexTrademarks Notice of CopyrightPurpose Conventions UsedAbout This Guide 975-0162-01-01 References to XPower PowerpackRelated Information About This GuideImportant Safety Instructions Warnings and CautionsWARNING Shock hazard. Keep away from children Do not expose the XPower Powerpack to temperatures over 104 F 40 C WARNING Explosion hazardWARNING Heated surface WARNING Fire hazardWARNING Fire hazard WARNING Risk of explosion, fire or burnsThe jump-start feature is designed for short term operation only- less than 4 seconds. Operating the jump-start feature for more than 4 seconds may cause damage to the unit. Allow the XPower Powerpack to cool down for at least 3 minutes after each jump- start WARNING Fire hazardWARNING Explosion and fire hazard Precautions When Working With Batteries10. If battery acid contacts skin or clothing, wash immediately with soap and water. If acid enters your eyes, immediately flood them with running cold water for at least twenty minutes and get medical attention immediately The output of the inverter is non-sinusoidal Precautions for Using Rechargeable Appliances1 Introduction ContentsImportant Safety Instructions 2 Features3 Operation 4 Maintenance5 Troubleshooting A SpecificationsB Warranty and Product Information Page Automatic overload About the XPower Powerpack1 Introduction Comprehensive ProtectionLow Battery Protection Jump-Start Cables Safety FeatureOverheating Materials List 2 Features1 DC Power Socket can XPower Powerpack FeaturesFront Panel Detail Feature DescriptionRequired Feature DescriptionAudible Alarm inside the unit sounds in the event shown of overheating or low battery protection on inverterCondition FeaturesRequired How to975-0162-01-01 Rear Panel Detail XPower Powerpack 400R onlyXPower Powerpack Features Feature DescriptionCondition Radio OperationRequired How to3 Valve connector with connector hose Air CompressorXPower Powerpack Features Feature DescriptionLeft Side View Feature Description2 Light ON/OFF Switch 400 Plus Light ON/OFF/Pulse Switch 400R 4 Red “emergency” light cover 5 Compressor Nozzle Adaptor Compartment Storage CompartmentXPower Powerpack 400R shown Feature Description2 Detachable heavy-duty jump-start cables AccessoriesFeature Description 4 Accessory bagOperating Conditions and Guidelines 3 OperationChoosing a Location WARNING Fire or explosionDry Cool Ventilated Safe Protected from battery gases Using XPower Powerpack for the First Time Recharging with the AC ChargerTo recharge with the AC Charger Using the light Operating AC AppliancesUnderstanding AC Appliances High Surge Appliances Run Time on Typical AC AppliancesOperating an AC Appliance Trouble AppliancesOperating Several Appliances at Once To operate an AC appliance CAUTION Equipment damage Operating 12 V DC AppliancesTo operate a 12 V DC appliance WARNING Fire hazard Jump-Starting a Vehicle’s EngineTo jump-start a vehicle or boat engine WARNING Fire hazard9. Remove the cables from the Jump-Start Cable Port WARNING Fire hazardWARNING Fire hazard Using the Air CompressorOver-Temperature Safety Protection WARNING Risk of personal injury or damage to equipmentTires Table 3-3 Pressure Specifications for Common ItemsInflating Tires WARNING Risk of personal injury or damage to equipmentTo inflate your vehicle, motorcycle, or bicycle tires Inflating Small Sports EquipmentUsing the Radio XPower Powerpack 400R To inflate small sports equipmentWARNING Fire hazard WARNING Fire hazard Connecting to an External BatteryPower Draw Listening to the AM BandWARNING Sparking and explosion WARNING Acid spills3-18 4 Maintenance Battery MaintenanceWARNING Shock hazard Recharging the XPower Powerpack Battery Recharging with the AC ChargerFunction button To recharge with the AC Charger Recharging with the DC Charging CableWARNING Fire and explosion hazard Recharging with a Generator’s Regulated 12 V DC Outlet Refer to the Owner’s Guide accompanying your generator for detailed instructions on connecting the generator to a unit like the XPower PowerpackWARNING Fire and explosion hazard To recharge with a solar panel Replacing the Internal BatteryBattery Life Recharging From a Solar PanelReplacing the Battery WARNING Shock or electrical hazard Obtaining a Replacement BatteryWARNING Fire hazard To replace the batteryReplacing the Incandescent Light 4. Tighten the fuse with the two bolts 5. Replace the fuse cover Replacing the External FuseMaintenance 1. Remove the fuse cover 2. Unscrew the two bolts on the fuseTelevision Interference 5 TroubleshootingCommon Problems Buzz in Audio EquipmentProblem Troubleshooting ReferenceTable 5-1 Troubleshooting reference WARNING Electric shock hazardPossible Cause ProblemSolution Troubleshooting ReferencePossible Cause Table 5-1 Troubleshooting referenceProblem SolutionCharging ProblemSolution Possible CausePossible Cause Table 5-1 Troubleshooting referenceProblem SolutionA Specifications Electrical Specifications12 V DC Section Internal Battery Charging Controller System AC Power SectionXPower Powerpack Physical SpecificationsRadio XPower Powerpack 400R only AccessoriesPage B Warranty and Product Information Warranty Proof of purchase may be in any one of the following forms Disclaimer ProductExclusions Warning Limitations On Use Return Material Authorization PolicyReturn Procedure Out of Warranty Service Purchase Date Information About Your SystemSerial Number Purchased FromPrinted in China e customerservice@xantrex.comf 1-800-994-7828 toll free in North America 1-360-925-5143 direct 975-0162-01-01