SECTION 3: ASSEMBLING YOUR LAWN TRACTOR
NOTE: This manual covers various models of hydrostatic tractors within the 690 series. Please use instructions pertaining only to your tractor.
Unpacking
•Remove all screws from top of the crate using 1/4" hex head socket or a flat blade screwdriver.
•To remove ends, grasp top board on the end, and pull towards you in downward motion. (A hammer may be helpful). Set panel aside to avoid tire damage.Repeat procedure on other sides.
•Remove and discard plastic bag which covers unit.
•Loose parts (may include the owner’s guide, steering wheel, optional oil drain sleeve or hose, battery fluid, chute deflector, optional mulching plug, etc.) are on the seat or in a box wrapped in plastic. Carefully cut and remove the plastic wrap. Remove the loose parts.
•Make sure that parking brake and hydrostatic transmission relief valve are released and unit is in neutral. See page
•Raise the deck and push the unit off the skid.
NOTE: Reference to right or left side of the unit is observed from the operating position on the driver’s seat, facing forward.
Tools Required
1.Socket wrench 1/4" or flat blade screwdriver
2.Adjustable or socket wrench 1/2" *
3.Adjustable or socket wrench 9/16"
4.Pair of adjustable or socket wrenches 7/16"
*If your tractor steering wheel cap is square, you must use a socket wrench to install the steering wheel.
Handling Battery
WARNING: The battery contains sulfuric acid. This battery acid must be handled with great care as contact with it can burn and blister skin. Wear protective clothing (goggles, rubber gloves and apron) when working with it.
Keep batteries out of the reach of children.
IMPORTANT: Should battery acid accidentally splatter into the eyes or onto the face, rinse the affected area immediately with clean, cold water. Refer to the antidotes mentioned below. If there is any further discomfort, seek prompt medical attention.
Antidote
Use the following antidotes if you come in contact with the battery acid.
EXTERNAL — Flush with water.
INTERNAL — Drink large quantities of water or milk. Follow with milk of magnesia, beaten eggs or vegetable oil. Call physician immediately.
EYES — Flush with cool water for at least 15 minutes, then get prompt medical attention.
If acid spills on clothing, first dilute it with clean water, then neutralize with a solution of ammonia/ water or baking soda/water.
IMPORTANT:Since battery acid is corrosive, do not pour it into any sink or drain. Before discarding empty electrolyte containers, rinse with a neutralizing solution.
WARNING: To avoid sparks, NEVER connect or disconnect charger clips to battery while charger is turned on.
Keep all lighted materials (cigarettes, matches, lighters) away from the battery as the hydrogen gas generated during charging can be combustible.
As a further precaution, only charge the battery in a
Identifying Battery Type
Type "A"
Type "B"
Figure 1
7
