Hustler Turf none manual Hardware Description Codes & Abbreviations

Page 8

Hardware Description Codes & Abbreviations

The following codes are used throughout this parts manual. Refer to this list when ordering parts.

ABBREVIATIONDESCRIPTION

CB

Carriage Bolt

CE

Clevis Pin

CP

Cotter Pin

CS

Cap Screw

CW

Cup Washer

FDRW

Fender Washer

FW

Flat Washer

HX

Hex Head

LW

Lock Washer

MB

Machine Bushing

MS

Machine Screw

NT

Nut

SC

Self Tapping Cap Screw

SH

Socket Head

SB

Shoulder Bolt

SS

Set Screw

OD

Outside Diameter

ID

Inside Diameter

Standard Torques

The following chart lists the standard torque values for the threaded fasteners found in this manual. Torque all cap screws, nuts and set screws to these values unless a different torque is shown in the Notes section next to the fastener

SIZE

FT-LBS

NM

SIZE

FT-LBS

NM

.250

8.2

11.1

M3

1

1.3

.312

17

23

M4

2.2

3

.375

30

40

M5

4.5

6.1

.438

48

65

M6

7.7

10.4

.500

73

99

M8

18.5

25

.562

105

143

M10

37

50

.625

145

200

M12

64

87

.750

260

350

M16

160

215

.875

420

565

M20

320

435

1.00

625

850

M24

555

750

NOTE:

Loctite 592 to be used on all pipe threads.

Lubricate all grease zerks.

1-2

333559 09/08

Image 8
Contents Hustler FasTrak 36 & 42 Decks Parts Manual Cl-2 333559 9/08 333559 9/08 Cl-3 Cl-4 333559 9/08 Table of Contents 333559 09/08 Service Literature General InformationFrequently Ordered Parts OptionsHardware Description Codes & Abbreviations Contents Tractor Frame Rivet Nut Installation DescriptionEngine Guard and Anti-rollover Bracket Assemblies Footrest Assembly Contents Battery Installation Harness BLKDeck Lift Assembly Deck Lift LinkHydro Transmission Installation S/N Prior To Index Service MFG. Part QTY Description Hydro Transmission Installation S/N Higher Than Torque to 17 ft.-lbs Hydro transmission service parts Steering and Brake Assembly QTY Description 333559 09/08 Contents Honda 16 HP Engine Installation Honda 16HP Engine Used on 333559 09/08 This page intentionally left blank Kohler 15 & 17 HP Engine Installation Kohler 15 HP Engine SV470S 333559 09/08 This page intentionally left blank Fuel System Installation Torque to 20 ft.-lbs Service parts not shown for fuel system Instrument Panel Installation Choke Cable Kohler Honda 16HP Electrical Schematic Honda 16HP Electrical Schematic Kohler 15 & 17 HP Electrical Schematic 601127 Kohler 15 & 17 HP Electrical Schematic 601127&793117 This page intentionally left blank 333559 08/08 Front Wheel Assembly Caster ForkFront Wheel Breakdown Drive Wheel Assembly Contents Deck Assembly Discharge Chute Base Deck Pulley Assembly Idler PULLEY, 5.00OD, 5/8ID 333559 09/08 This page intentionally left blank Deck Assembly Index Service 1412 333559 09/08 793893 333559 09/08 This page intentionally left blank Blade Spindle Assembly Breakdown 333559 08/08 This page intentionally left blank Contents Deck Installation Belt Routing and Tensioning Seat Installation Contents Tractor Decals Deflector Shield Decal Deck Decals 793513 333559 Maintenance & Adjustment Safety Adjustments Maintenance & Adjustment Safety Safe Maintenance & Adjustment PracticesUsing a ramp Children Safety and Instruction Decals Part Number 794297 Maintenance ChartService AT Intervals Indicated Weekly or 50 Annually Hours References IntroductionTorque values TiresLubrication Electrical systemMain 20 amp, blade type Clutch/Aux 10 amp, blade type Access to integrated pump/motor units Hydraulic systemFuel system Fuel Tank Engine oil and filter Draining the Fuel TanksEngine OIL Drain Plug Belt replacement Engine mounting boltsIntegrated pump/motor drive replacement Mower blade maintenance Original edge Warped Blade Replace Steering linkage adjustment AdjustmentsPark Brake Adjustment Control lever neutral adjustment Front Damper Ball Stud JAM NUT Pump ROD Adjuster Assembly Steering dampener adjustment Hydraulic pump belt adjustmentDeck leveling and height adjustment Deck drive belt adjustmentEngine RPM setting Height Stop Handle Height Adjusting Deck Lifting ARM Nuts Numerical Index Part