Husqvarna HUV 4421-D / DXP, HUV 4421-G / GXP owner manual Periodic Service Schedule

Page 31

Periodic Service Schedule

ýWARNING

-Gasoline vehicles only: Disconnect the spark plug wires from the spark plugs.

•If wires are removed or replaced make sure wiring and wire harness are properly routed and secured. Failure to properly route and secure wiring could result in vehicle malfunction, property damage, personal injury, or death.

•Lift only one end of the vehicle at a time. Use a suitable lifting device (chain hoist or hydraulic floor jack) with 1000 lb. (454 kg) minimum lifting capacity. Do not use lifting device to hold vehicle in raised position. Use approved jack stands of proper weight capacity to support the vehicle and chock the wheels that remain on the floor.

•When servicing the vehicle with part of the vehicle on jack stands, do not operate the engine with the Forward/Reverse handle in either the FORWARD or REVERSE position. The all-wheel drive system will engage any wheel(s), front or rear, with traction. See Figure 2 on page 9.

PERIODIC SERVICE SCHEDULE

See General Warnings on page 8.

ýWARNING

•Service, repairs, and adjustments must be made per instructions in the appropriate maintenance and service manual.

NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance procedures should be performed more often than recommended in the Periodic Ser- vice and Lubrication Schedule.

Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to keep vehicle in optimum operating condition.

PERIODIC SERVICE SCHEDULE

REGULAR INTERVAL

SERVICE

 

 

 

 

 

 

Daily service by owner

 

Check engine oil level; add if necessary.

 

or trained technician

 

See Engine Oil Level Check on

 

 

Engine

page 35.

 

 

 

 

 

Diesel vehicles: Check engine coolant;

 

 

 

 

 

 

add if necessary. See Engine Coolant

 

 

 

Level Check on page 42.

 

 

 

 

 

 

 

Diesel vehicles: Drain water from fuel

 

 

Fuel filters

filter. See Draining Water from Fuel

 

 

 

Filter on page 45.

 

 

 

 

 

 

 

Check brake fluid; add if necessary.

 

 

Brakes

Check brake pedal for proper operation.

 

 

 

See Performance Inspection on page 18.

 

 

 

 

 

Periodic Service Schedule continued on next page....

 

 

 

 

 

 

2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual

Page 29

Page 30 Page 32
Image 31
Page 30 Page 32
Contents 2007 Utility Vehicles Page USA Foreword Table of Contents ALL HUV 4421 Models DRIVER/PASSENGER Warning Decal Rotating Parts Decal Diesel Vehicle Feature Identification DAN G E R Caut ION Safety DetailsCaut ION DAN G E R General WarningsAll-wheel Drive Warning See General Warnings on Controls and IndicatorsGeneral Information Model IdentificationControls and Indicators Accelerator Pedal KEY Switch Gasoline VehiclesKEY Switch Diesel Vehicles FORWARD/REVERSE ControlPark Brake Steering Adjustment LockVolt Accessory Outlet Brake PedalHeadlight Control HIGH-TEMPERATURE Warning Light Diesel Vehicles onlyLOW OIL Warning Light Fuel GAUGE/HOUR MeterRelease Safety Belt ROLL-OVER Protective Structure and Safety BeltsING Seat Latch and AdjustmentExhaust system Check for leaks PRE-OPERATION and Daily Safety ChecklistDriving Instructions Performance InspectionStarting the Vehicle ALL-WHEEL Drive AWD Operation Stopping the Vehicle BED Latch and Prop RODParking and Leaving the Vehicle Bed Latch Loading and Unloading CargoVehicle Load Capacities Transporting on a Trailer Towing with the VehicleSee General Warnings on DAN G E R StorageOFF Preparing the Vehicle for Extended StorageGasoline vehicles Returning the Stored Vehicle to ServiceMaintenance MaintenancePeriodic Service Schedule Periodic Service ScheduleMonthly service by owner Annual service by Periodic Lubrication Schedule Periodic Lubrication ScheduleLubrication Points Gasoline Vehicles OIL Pressure Gasoline Engine Brake Fluid ReservoirEngine OIL Brake FluidDo not remove dipstick while engine is running Engine OIL Level CheckEngine Oil Draining Engine OIL and Filter ChangeDrain the engine oil. See Engine Oil Draining on Engine Oil Filter ChangeRemove Engine Oil Filter OIL Viscosity Engine Oil FillingFront differential Gearcase LubricationRear differential TransmissionEngine Coolant Level Check AIR Filter ReplacementEngine Coolant Diesel Vehicles AIR Intake SystemFueling Instructions Air Filter InstallationAir Filter Removal Fuel Tank Gasoline Vehicles Biodiesel Fuel Diesel Vehicles OnlyDiesel Vehicles Only Draining Water from Fuel FilterFuel Filter BatteryBattery Jump Starting Using a Booster Battery Jump StartingSee following Note Cleaning the VehicleAccessories Electric Winch AccessoryMUD Tire Option Subsequent Owner RegistrationSpecifications Vehicle SpecificationsDIMENSIONS/WEIGHT Tire Pressure Warranty Information Carburetor Modification for High Altitude Operation Technical & Consumer Information Gasoline EnginesOxygenated Fuels Maintenance U.S. and California Clean Air ActsProblems That May Affect Emissions Replacement PartsYour Warranty Rights and Obligations California Emission Control Warranty StatementPage Page Page Husqvarna Part Number 531 30 Edition Code 0706C0307B
Top Page Image Contents