Generac 004451 ,004582, 004451, 004582 Storage General, Long Term Storage, Other Storage Tips

Page 20

Section 3 — Maintenance

Commercial-Industrial-Residential Portable Generator System

STORAGE

3.7 GENERAL

The generator should be started at least once every seven days and be allowed to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30 days, use the following information as a guide to prepare it for storage.

DANGER! NEVER store engine with fuel in tank indoors or in enclosed, poorly ventilated areas where fumes may reach an open flame, spark or pilot light as on a furnace, water heater, clothes dryer or other gas appliance.

3.8 LONG TERM STORAGE

It is important to prevent gum deposits from forming in essential fuel system parts such as the carburetor, fuel hose or tank during storage. Also, experience indicates that alcohol-blended fuels (called gasohol, ethanol or methanol) can attract moisture, which leads to separation and formation of acids during storage. Acidic gas can damage the fuel

system of an engine while in storage.

To avoid engine problems, the fuel system should be emptied before storage of 30 days or longer, as follows:

• Remove all gasoline from the fuel tank.

DANGER! Drain fuel into approved container

outdoors, away from open flame. Be sure engine is cool. Do not smoke.

•Start and run engine until engine stops from lack of fuel.

•While engine is still warm, drain oil from crankcase. Refill with recommended grade.

• Remove spark plugs and pour about 1/2 ounce (15 ml) of engine oil into the cylinders. Cover spark plug hole with rag. Press the “Start” button and allow engine to crank for 2 seconds. Then press the “Stop” button.

CAUTION! Avoid spray from spark plug holes when cranking engine.

•Install and tighten spark plugs. Do not connect spark plug wires.

•Clean the generator outer surfaces. Check that cooling air slots and openings on generator are open and unobstructed.

•Store the unit in a clean, dry place.

3.9 OTHER STORAGE TIPS:

•Do not store gasoline from one season to another.

•Replace your gasoline can if your can starts to rust. Rust and/or dirt in your gasoline will cause problems with the carburetor and fuel system.

•If possible, store your unit indoors and cover it to give protection from dust and dirt. BE SURE TO EMPTY THE FUEL TANK.

•If it is not practical to empty the fuel tank and the unit is to be stored for some time, use a commercially available fuel stabilizer added to the gasoline to increase the life of the gasoline.

•Cover your unit with a suitable protective cover that does not retain moisture.

DANGER! NEVER cover your generator while engine and exhaust area are warm.

18

Page 19 Page 21
Image 20
Page 19 Page 21
Contents Ultra Source Safety Rules General Information Introduction Important Safety Instructions General HazardsFire Hazards Electrical HazardsExplosion Hazards Assembly Accessory BOXUnpacking Assembling the Wheel KITBattery Connection Handle AssemblyWinter / Summer Valve See Cold Weather Operation Know the GeneratorVolt AC, 30 Amp Locking Receptacle Supplies 2 120V AC, 20 AMP, Gfci Receptacle Cord Sets and Connection Plugs1 AC, 20 AMP, Duplex Receptacle 120V 30A 5 12 Volt DC, 10 AMP ReceptacleHOW to USE the Generator Connecting Electrical LoadsDON’T Overload the Generator Grounding the GeneratorWattage Reference Guide Before Starting the GeneratorAdding Engine OIL DeviceTo Start the Engine Adding GasolineAutomatic Idle Control Cold Weather OPERATION/ DE-ICERLOW OIL Pressure Shutdown System Stopping the EngineCharging a Battery To recharge 12 Volt batteries, proceed as followsMaintenance Schedule Product SpecificationsGenerator Specifications Engine SpecificationsGeneral Recommendations Service AIR Cleaner Clean Spark Arrestor ScreenAdjusting Valve Clearance To adjust valve clearanceOther Storage Tips Storage GeneralLong Term Storage Troubleshooting Problem Cause SolutionCommercial-Industrial-Residential Portable Generator System Commercial-Industrial-Residential Portable Generator System Wiring Diagram Drawing No E0228 Bearing Stator ClosestSchematic Drawing No E0229 46 45 43 42 GT-990 & GT-760 Engine Page 1 Drawing No E0034QTY Description Detaila GT-990 & GT-760 Engine Page 2 Drawing No E0034Part NO. QTY Description Generator Drawing No D4488 QTY. Description Exploded Residential No E0227 Part NO. QTY. Description Control Panel Drawing No E0227Detail Frame, Handle & Wheel Kit Drawing No E0695Rubber Tank Mount California Emission Control Warranty Statement BOX 297 WHITEWATER, WIEmission Control System Warranty Warranty Schedule Part No E0226 06/01/02

004451, 004582, 004451 ,004582 specifications

Generac is a leading manufacturer of power generation equipment, known for its robust and reliable systems. Among its vast lineup, the Generac 004451 and 004582 portable generators stand out due to their impressive features, advanced technologies, and user-friendly characteristics, making them suitable for various applications such as home backup, outdoor activities, and job sites.

The Generac 004451 model boasts a powerful 2,500-watt output, making it ideal for powering essential appliances during outages or for use in recreational settings. Its compact design enhances portability, allowing users to easily transport it wherever needed. This generator features a durable frame designed to withstand rugged environments, including a fold-down handle for convenient storage. It is equipped with a reliable 50-state compliant engine, ensuring that it meets stringent environmental regulations while delivering dependable power.

On the other hand, the Generac 004582 model is designed for users needing a bit more power, featuring a 3,200-watt maximum output. Like the 004451, it emphasizes portability and ease of use, but it also incorporates a more advanced inverter technology. This innovation ensures that the generator produces clean, stable power, making it safe for sensitive electronics like smartphones, laptops, and medical devices. The 004582's lightweight construction allows for effortless transport, while its fold-down handle and never-flat wheels enhance mobility.

Both models are engineered with user-friendly controls and features such as easy-to-read fuel gauges and a low-oil shutdown system, which prevents engine damage by automatically shutting down the generator when the oil level is too low. Additionally, these generators include multiple AC outlets, offering versatility in powering various devices simultaneously.

Safety is paramount in Generac's design philosophy, as evident in the inclusion of features such as circuit breakers to prevent overloads. Additionally, they are equipped with a robust cooling system that allows for prolonged operation without overheating.

Overall, the Generac 004451 and 004582 portable generators provide a perfect blend of power, portability, and technological advancements, making them suitable for emergency backup power, outdoor events, and job site requirements. With a strong emphasis on reliability and user convenience, Generac continues to be a trusted name in the field of power generation.
Top Page Image Contents