Briggs & Stratton 030211 owner manual Cold Weather Operation, Battery Charger

Page 11

6200W Portable Generator

Figure 6 — 120 Volt, 20 Amp Duplex Receptacle

COLD WEATHER

OPERATION

Under certain weather conditions (temperatures below 40°F [4°C] and a high dew point), your generator may experience icing of the carburetor and/or the crankcase breather system.

Build a structure that will enclose three sides and the top of the generator:

1.Make sure entire muffler-side of generator is exposed. Note that your generator may appear different from that shown in Figure 8.

Use each receptacle to operate 120 Volt AC, single–phase, 60 Hz electrical loads requiring up to 2,400 watts (2.4 kW) at 20 Amps of current. Use cord sets that are rated for 125 Volt AC loads at 20 Amps (or greater).

BATTERY CHARGER

Use battery float charger jack to keep the starting battery charged and ready for use. Battery charging should be done in a dry location, such as inside a garage.

1.Plug charger into unit’s “Battery Float Charger” jack, which is located on the starter switch (Figure 7). Plug battery charger into a 120 Volt AC wall receptacle.

Figure 7 — Battery Charger Jack

Figure 8 — Permanent Cold Weather Shelter

Wind

2.Unplug charger from unit and wall outlet when generator is being started and while it is in operation.

3.Keep this charger plugged in when generator is not in use to prolong battery life.The charger has a built in float equalizer and will not overcharge the battery, even when plugged in for an extended period of time.

IMPORTANT: See “Battery Maintenance” on page 13 for additional information.

2.Ensure a minimum of two feet clearance between open side of box and nearest object.

3.Face exposed end away from wind and elements.

4.Enclosure should hold enough heat created by the generator to prevent problems.

DANGER

Running generator gives off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide will cause nausea, fainting or death.

Operate generator ONLY outdoors.

Keep at least 2 feet of clearance on all sides of generator for adequate ventilation.

DO NOT operate generator inside any building or enclosure, including the generator compartment of a recreational vehicle (RV).

Remove generator from shelter when temperature is above 40°F [4°C].

11

Image 11
Contents 030211 6200W Equipment Description Table of ContentsSafety Rules When Transporting or Repairing Equipment When Adding or Draining FuelWhen Starting Equipment When Operating EquipmentWhen Testing for Engine Spark When Adjusting or Making Repairs to Your GeneratorKnow Your Generator Electric Start AssemblyCarton Contents Check Battery / Attach Negative Battery WireRefer to and install the wheel kit as follows Install Wheel KITAdd Engine Oil When Adding FuelBefore Starting the Engine Add FuelSystem Ground Using the GeneratorConnecting to a Building’s Electrical System Operating GeneratorStopping the Engine Connecting Electrical LoadsReceptacles 120/240 Volt AC, 30 Amp, Locking ReceptacleCold Weather Operation Battery ChargerExample Power ManagementDont Overload Generator CapacityGeneral Maintenance Recommendations SpecificationsEngine Storage Other Storage Tips StorageGenerator Storage Problem Cause Correction TroubleshootingSchematic Wiring Diagram Exploded View Main Unit Parts Not Illustrated Exploded View Parts ListDescription Stator Exploded View and Parts List AlternatorExploded View and Parts List Control Panel Wheel Exploded View and Parts List Wheel KITLimited Warranty Advertencia Tabla DE ContenidosDescripción DEL Equipo Instrucciones DE SeguridadCuando Opere EL Equipo PeligroCuando Añada Combustible O Vacíe EL Depósito Cuando Ponga EN Funcionamiento EL EquipoCuando Pruebe LA Bujía DEL Motor PrecauciónCuando Ajuste O Haga Reparaciones a SU Generador Conozca SU Generador Contenido de la Caja MontajeArranque Eléctrico Para Retirar El Generador De La CajaInstale el Juego de Ruedas Como Sigue Figura Instale EL Juego DE RuedasCuando Añada Combustible Antes DE Darle Arranque AL MotorAgregar Aceite al Motor Agregue CombustibleConexión al Sistema Eléctrico de un Edificio USO DEL GeneradorOperando EL Generador Precaución Tierra del Sistema120/240 Voltios AC, 30 Amp, Receptáculo de Seguridad Receptáculos PrecauciónConexion De Cargas Electricas Parado Del MotorOperación Durante UN Clima Frío Cargador DE BateríaEjemplo No Sobrecargue GeneradorCapacidad Control de la EnergíaRecomendaciones Generales DE Mantenimiento EspecificacionesOtras Sugerencias Para el Almacenando AlmacenamientoAlmacenando el Generador Almacenando el MotorDiagnositicos DE Averías Problemo Accion CausaNotas Notas Garantía Limitada