Matsushita CF-18NHHZXBM service manual Setting the Display Unit, Assembly of Display Unit

Page 36

7.2.6.Setting the Display Unit

1. Fix the Display Unit using the 2 Screws <T>.

<T>	Hinge Cover

<T>

3.Turn the computer over and fix the LCD Hinge Cover using the 2 Screws <S>.

4.Open the Display Unit and fix the LCD Hinge Cover using the 2 Screws <S>.

Screws <S> : DFHE5025XA

Screws <T> : DRSB2+5FKL

Screws <U> : XYN4+J8FNL

<S>

<S>

LCD Hinge Cover

2. Close the Display Unit and turn the computer over, and then fix the Display Unit using the 4 Screws <U>.

<U> <U> <U>

<U>

<S> <S>

!Assembly of Display Unit

Safety Working

Detail of "A"

Note

Avoid any stress on the Cable.

Screw<U> Screw<U>

Screw<U> Screw<U>

Hinge Cover
Cable
Cushion
LCD Cable
white/black	blue/ glay/brown

LCD UNIT

Top Case Assy

A

Close the LCD and turn it over.

< Order of fixing screw>

Take out the Cables.

Pass all of the Cables into the KBD Hole.

7-17

Image 36

Contents CF-18 How to replace the fuse For U.K This apparatus must be earthed for your safetyLaser Safety Information Page Page Contents Diagnosis Procedure Basic ProcedureTroubleshooting Error Diagnosis by Checking Beep Signal Sound Table of errors classified by beep soundsOutline of Post Stuck key 02F4 Eisa Cmos not writable Equipment PreparationSelf Diagnosis Test Vesa Mode Test Speaker TestCPU A20 Gate Test Cache ON/OFF TestLAN Test Modem Test Wireless LAN Test Peripheral TestTest Selection End of test Error Messages and Troubleshooting Test classification Screen display test items ContentsPCB CN880 TouchScreen Panel Removing the Battery Pack and HDD Pack Removing the Touch Pad and Key- boardHDD FPC Removing the Speaker Angle and Dimm Lid Removing the Rear CabinetKBD FPCRemoving the DU Lid Unit Wireless Module Port PCB and Modem Removing the Audio PCBRemoving the SD PCB DU LIDRemoving the Main PCB and Lith- ium Battery Removing LED PCB and SwitchRemoving the PAD PCB and I/O Removing the CPU Heat PlateRemoving the Display unit Removing the LCD Rear Case Removing the LCD HingeLCD Removing Inverter PCB and LCD Removing the Each Cover Unit Reassembly Instructions Setting up the LCD UnitSafety Working Assembly of Touch Screen Applicable Model Touch Screen Model Touch Screen AssyAssembly of Glass Applicable Model Digitizer Model Glass AssyLine processing of Antenna Cable GprsSetting up the LCD Hinge Assembly of LCD HingeCable Hold Plate ScrewY Line processing of Antenna Cable and LCD Cable ANT CableHIinge Cover LCD CableAssembly of LCD Front Case Display UnitAssembly of LCD Rear Case Applicable Model Digitizer Model Assembly of Tablet Latch Cover and Antenna Cover ANT CoverSetting the Display Unit Assembly of Display UnitSetting the CPU Heat Plate Modem CableSetting the LED PCB and the Switch PCB Assembly of the LED PCB and the Switch PCBPET Tape Setting the PAD PCB and the I/O PCB Assembly of PAD PCBAssembly of TOP Case Assy Putting of the PAD Insulation SheetSetting the Main PCB and the Lithium Battery Line Processing of the Antenna CableLine Processing of the Lithium Battery Pass the Lead Wire through the notch of the BoardLine Processing of Main Unit CN3Setting the SD PCB Assembly of SD PCBSetting the Wireless Module, the Port PCB, and the Modem Assembly of the Port PCBLine Processing of the Wireless Module,Port PCB and Modem CableScrew DU Sponge aSetting the Audio PCB Assembling the DU Lid UnitPutting of the Sheet Mm width x 5.5 cmSetting the Rear Cabinet Setting the Speaker and Dimm Lit DisplacementSetting the Touch Pad and the Keyboard LCD Cushion Sheet KBD Waterproof Sheet RKB CNT Hole CushionPutting of the Palm Rest Assy Keyboard KBD TapeScrew Screw Screw KBD PlateL ScrewSetting the Battery Pack and the HDD Pack Assembly of the HDD AssyAssembling the Each Cover RGBExploded View BT1 E42 K409 K210 K200-30 K211 K200-30-4 K200-30-35 K200-30-35-1 K220 Screw tightening torque Wireless LAN Module Description QTYPCB, Main RTL PCB, Audio RTLDFJK13T024DB FFC, PAD PCB, Wide Area AUX Antenna RTLDFJS977ZA CABLE, Wide Area AUX ANT. Brown DL3U7B482AAA PCB, SD RTLDFHR3551YA Coin Battery Sheet Power SW KnobDFHR3262ZA Modem Tape DFHR3301YA Mini PCI Card SheetTOP Case Assy Tablet Latch AssyBatt LID Assy DFBH3030ZA LID HingeDFHR3477ZA Spacer B DFHR3630ZA TS FPC SpacerDFHR3674YA TS Tape DL3DV0180AAA TS Panel AssyDXYN2+J12FNL Screw DXYN2+J18FNL ScrewDRHM0061ZA Screw DXYN4+J8FNL ScrewRTC Battery Main PCBEEFCD0D151ER Page Page Page Page EEFCX0D331R EEFCD0D101EREEFCX0D221R EEFUD0J151ER EEFCX0J101R Connector EEFCX0G151REEFCD0G101ER EEFCD0J470ERIC, USB Power Control DEDRB081L20 DiodeFUSE, 5A FUSE, 2AIC, Micon IC, ReguratorIC, 1 Gate Logic IC, Gate Logic DA2205IDBLET IC, Bipolar LogicDDAZS100MT3T Inductor Poly SWTransistor DETA144EETL Transistor Transistor ERJ2GEJ681X ERJ2RKF27R4XERJ2RKF54R9X ERJ2RKF39R2XERJ2GE0R00X RESISTOR, 1/16W, 0Ω ERJ2RKF80R6X RESISTOR, 1/16W ERJ2GEJ103X RESISTOR, 1/16WERJ2GEJ222X ERJ2GEJ101XERJ2RKF1002X RESISTOR, 1/16W, 10KΩ Resistor Array ERJ2RKF1501XERJ2GEJ390X ERJ2RKF2550XERJ2GEJ102X RESISTOR, 1/16W, 1KΩ ERJ2GEJ2R2XERJ2RKF49R9X ERJ2GEJ330X ERJ2RKF4750XERJ2GEJ1R0X RESISTOR, 1/16W, 1Ω ERJ2GEJ104XERJ2RKF22R6X DEARA8AJ103M Resistor ArrayERJ2GEJ472X ERJ2GEJ203X RESISTOR, 1/16W, 20KΩERJ2GEJ473X RESISTOR, 1/16W, 47KΩ ERJ2GEJ181XERJ2GEJ221X ERJ2GEJ471XERJ2RKF1302X RESISTOR, 1/16W, 13KΩ ERJ2GEJ474XERJ2RHD752X ERJ2RKF2002X RESISTOR, 1/16W, 20KΩERJ2RHD302X RESISTOR, 1/16W, 3KΩ ERA3YKB104VERA3YEB333V RESISTOR, 1/16W, 33KΩ TranceIC, AC97 Codec IC, Audio AMPERJ2GEJ103X RESISTOR, 1/16W, 1KΩ ERJ2GEJ273X RESISTOR, 1/16W, 27KΩConnector DFJS830YA EZASCE101M Capacitor ArrayERJ2RKF75R0X IC, Flat PAD ControllerERJ2GEJ822X ERJ2GEJ103X RESISTOR, 1/16W, 10KΩEVQPLDA15 LEDERJ2GEJ303X RESISTOR, 1/16W, 30KΩ ERJ6GEYJ101V