Matsushita CF-29N3LGZBM Setting the Antenna PCB L and R, Arranging the Antenna L and R Cables

Page 28

7.2.Reassembly Instructions

7.2.1.Attention when CF-29 series is repaired

•Please execute writing BIOS ID when you exchange the Main Board.

•You cannot reuse the Conductive Clothes and the heat dissipating parts such as Sheet and Rubber. Use new parts.

7.2.2.Setting the Antenna PCB L and R

1.Set the Antenna PCB L and R to the LCD Rear Cabinet Ass’y.

2.Fix the Antenna PCB Cover L and R using the four Screws. <i>

Screws <m>: DRSB26+8KL

■Arranging the Antenna L and R Cables

LCD Rear Cabinet Ass’y

Antenna PCB L

<m>

	<m>
	Antenna PCB	<m>	Antenna PCB R
	Antenna PCB	<m>	Antenna PCB Cover R
	Cover L	<m>	Antenna PCB Cover R

View "A"	View "A"
Antenna Cable L	Antenna Cable R
View "B"	View "B"

View "A"

<No good>

LCD Rear

Cabinet

		Do not press too
	Antenna	much the
	Antenna	Waterproof Cap.
	Cable	Waterproof Cap.
	Cable

View "B"

Tape		Tape
View "C" Tape	Tape	View "C"
	View "D"

Cushion

View "E"

Waterproof Cushion Cable Clamper

Antenna Cable R

Pass the Antenna Cable through this space.

Tape

align

View "E"

View "D"

View "C"

Waterproof

Cushion

Cable Clamper

Bend

LCD Rear

Cabinet

Antenna Cable L and R

	LCD Rear Cabinet
1~5mm	1~5mm
1~4mm		1~4mm
Tape	Antenna Cable L	Tape
Antenna Cable R

Pass the Antenna Cable

through this space.

Antenna Cable L

align

Tape

7-10

Image 28

Contents CF-29 How to replace the fuse For U.K This apparatus must be earthed for your safetyLaser Safety Information Page Page Contents Diagnosis Procedure Basic ProcedureTroubleshooting Flow ChartTable of errors classified by beep sounds Error Diagnosis by Checking Beep Signal SoundOutline of Post Stuck key 02F4 Eisa Cmos not writable Equipment PreparationSelf Diagnosis Test Vesa Mode Test Speaker TestCPU A20 Gate Test Cache ON/OFF TestModem Test Wireless LAN Test CD Test LAN TestTest Selection Error Messages and Troubleshooting Wiring Connection Diagram Removing the Battery Pack, HDD Pack and FDD Pack Removing the HDDHDD FPC HDDRemove the KB Cable Cover, Keyboard and Pcmcia Protector Removing the KBD PCB, MDC Modem and LCD Cable/MIC Frame Removing the Dimm Cover and Bottom CoverRemoving the Wireless Module Removing the SpeakerPAD SW FFC Removing the TP PCB Remove the HDD Main FPCRemoving the IO PCB Removing the Handle and Power Removing LCD Unit Removing LCD Rear Cabinet, Hinge Hinge R Removing the Inverter PCB, TS PCB and LCD Unit Removing the Antenna PCB LSetting the Antenna PCB L and R Arranging the Antenna L and R CablesSetting the Inverter PCB, TS PCB and LCD Unit View aAttaching the Touch Screen Panel TS FPCView B2 Arranging the Inverter PCBArranging the LCD Back Holder LCD Unit LCD Hold Plate L LCD Plate R LCD Metal Damper TS PCB Attaching the Inverter PCB and TS PCBPCB View E Arranging the CablesSetting the LCD Rear Cabinet, Hinge L and Hinge R Setting the LCD unitSetting the Handle and Power SW Arranging the SW LED PCB PW LED PCBArranging the Power SW Cable SW LED PCBSetting the IO PCB Arrange the IO FPCIO FPC IO FPC LID SWIO PCB Setting the IO FPCIO PCB LID SW Setting the TP PCB Attaching the Cable Sheet, Insulation Sheet and the SheetLED FFC TP PCBSetting the HDD Main FPC Arranging the HDD Main FPCNo4 Setting the LAN Cable and Modem Cable Setting the Main PCB Main PCB LAN Cable Clamper SlotView D View C Setting the RTC Battery Setting the PAD SW FFC Cover View C Setting the Wireless Module and SD PCBMini PCI Setting the Speaker Attaching the Memory Heat PlateSetting the Dimm Cover and Bottom Cover Arranging the Dimm Cover and the Dimm Radiation SheetSetting the KBD PCB, MDC Modem and LCD Cable/MIC Frame Attaching the Sheet to the MDC ModemArranging the Cables and setting the LCD Cable/MIC Frame Setting the KB Cable Cover, Keyboard and Pcmcia Protector Arranging the KeyboardHinge Cover L No2 C No10 B No3 C No11 No4 No7 No5 Setting the HDD Attaching the SheetSetting the Battery Pack, the HDD Pack and the FDD Pack Exploded View 19 ± 0.02 N.m 441 + 0.049 N.m 19 + 0.02 N.m 2.0 + 0.2 kgf.cm 45 + 0.05 N.m Screw tightening torque 19 + 0.02 N.m Screw tightening torque Wireless LAN Module DFJS865ZA Power SW CableBattery Pack DFJS954ZA Modem Cable Description QTYPower SW Assy DFUQ0099ZA Power SW SpringPower SW Knob Power SW ARMDFHR3497YA Power SW Sheet PC Latch AssyPC Latch Lever DFMD1161ZA PC Latch AngleDFMX1006ZA Cable Sheet DFGT1055ZA Bottom Cover Sheet aDFHG370ZA Foot Rubber DFHP7162ZA HD FPC TapeDFHM0304YB MDC Spacer DFHM0330YB CN SpacerDRHM5118ZA Screw DFHR3713ZA Mini PCI Spacer U2DFHR3747ZA Power SW PWB Cushion DFHR3743YA Power LED Packing SheetDFHR3778ZA Battery Angle Sheet W DFMD7A49ZA Connector RingDFHR5440YA GUIDE, FDD Connector DFHR4050ZA TUBE, LEDDFHR8295ZC LS DAMPER, UNDER-1 DFHR8296ZB LS DAMPER, UNDER-2RTC Battery QTYEEFCD0D151ER Page Page Page Page Page EEFCX0D331R EEFCD0D101ER EEFCX0D221REEFUD0J151ER ECJ2FF1A106ZEEFCX0J101R EEFCD0G101ERDCUI1C106HDB EEFUE0J181ERThermistor ConnectorDiode IC, USB Power Control DED10QS04TL DiodeFUSE, 5A FUSE, 2AIC, Audio AMP IC, Gate LogicIC, Eeprom IC, Security ChipInductor Inductor DDB5Z031J-LInductor DDB5Z021C-Y Inductor ETQP4LR56WFCDETA144EETL Transistor Transistor B1GKCFJN0004 ERJ2GEJ681X ERJ2RKF27R4XERJ2RKF54R9X ERJ2RKF39R2XERJ2GEJ562X ERJ2GEJ750XERJ2RKF2210X ERJ2RKF1000XERJ2RKF80R6X RESISTOR, 1/16W ERJ2GEJ103X RESISTOR, 1/16WERJ2GEJ222X ERJ2GEJ101XERJ2RKF1500X ERJ2RKF1501XERJ2GEJ390X ERJ2RKF2550XERJ2GEJ102X RESISTOR, 1/16W, 1KΩ Resistor ArrayERJ2GEJ1R0X RESISTOR, 1/16W, 1Ω ERJ2GEJ120XDEARA8AJ103M Resistor Array ERJ2RKF22R6XERJ2GEJ472X ERJ2GEJ203X RESISTOR, 1/16W, 20KΩ ERJ2GEJ106X RESISTOR, 1/16W, 10MΩERJ2GEJ105X RESISTOR, 1/16W, 1MΩ ERJ6GEYJ680VERJ2RKD154X DEARA8CJ330M Resistor ArrayERJ2GEJ100X ERJ2RKF3010XERJ2GEJ363X RESISTOR, 1/16W, 36KΩ ERJ2GEJ333X RESISTOR, 1/16W, 33KΩERJ2GEJ223X RESISTOR, 1/16W, 22KΩ ERJ2GEJ683X RESISTOR, 1/16W, 68KΩERJ2RKF5602X RESISTOR, 1/16W, 56KΩ ERJ2RKF1600XERJ2RKF2150X ERJ2RKF7501XERJ2RHD3652X ERJ2GEJ154XERA3EKB1623V ERA3EEB1692VDDB5Z024E-L Inductor DDB5Z021G-Y InductorPoly SW ERJ3GEYJ102V RESISTOR, 1/16W, 1KΩ LEDIC, Flat PAD Controller B1GKCFJN0004 TransistorERJ2GEJ224X ERJ2GEJ822XResistor Array EVQPLDA15 LED EVQPLDA15