Matsushita CF-29N3LGZBM manual Setting the IO PCB, Arrange the IO FPC, Io Fpc Lid Sw

Page 39

7.2.8.Setting the IO PCB

1. Fix the IO PCB using the six Screws<d>. No1 to No6

Note:

Tighten the Screws in the numbered order (No1 to No6). Screws <d>: DFHE5058ZB

■Arrange the IO FPC

Rear I/O FPC Cover Sheet

IO PCB

<d>

:No1 <d> <d> :No3 :No4

<d> :No5 <d>

:No6 <d> :No2

Safety Working

View "A"

IO FPC

R1.5~2.5mm

0±0.3mm

View "B"

IO FPC

LID SW

Cushion

Attention when bending the FPC

1.Inside of bending should be from R0.5mm to R1mm.

2.Do not mistake the direction of bending.

3.For bending point, it should be within 0.5mm from the white line unless there is a regulation.

<No good>

R0.5~1.0mm

2~3mm

Bend 90

White line

White line

LID SW Cushion

View "A"

0±0.5mm

Bend

180 1~1.5mm

View "B"

0±0.5mm

Front side

Bend 180

	IO FPC
		White line
		Bend
		90
	White line	0~0.5mm
		0~0.5mm
	Bend	White line
	Bend	White line
	90	White line
	90
		LID SW Cushion
		Bend
		90
		Back side

7-21

Image 39

Contents CF-29 For U.K This apparatus must be earthed for your safety How to replace the fuseLaser Safety Information Page Page Contents Basic Procedure Diagnosis ProcedureFlow Chart TroubleshootingError Diagnosis by Checking Beep Signal Sound Table of errors classified by beep soundsOutline of Post Stuck key 02F4 Eisa Cmos not writable Preparation EquipmentSelf Diagnosis Test Cache ON/OFF Test Vesa Mode TestSpeaker Test CPU A20 Gate TestLAN Test Modem Test Wireless LAN Test CD TestTest Selection Error Messages and Troubleshooting Wiring Connection Diagram HDD Removing the Battery Pack, HDD Pack and FDD PackRemoving the HDD HDD FPCRemove the KB Cable Cover, Keyboard and Pcmcia Protector Removing the Dimm Cover and Bottom Cover Removing the KBD PCB, MDC Modem and LCD Cable/MIC FrameRemoving the Speaker Removing the Wireless ModulePAD SW FFC Remove the HDD Main FPC Removing the TP PCBRemoving the IO PCB Removing the Handle and Power Removing LCD Unit Removing LCD Rear Cabinet, Hinge Hinge R Removing the Antenna PCB L Removing the Inverter PCB, TS PCB and LCD UnitArranging the Antenna L and R Cables Setting the Antenna PCB L and RTS FPC Setting the Inverter PCB, TS PCB and LCD UnitView a Attaching the Touch Screen PanelArranging the Inverter PCB View B2Arranging the LCD Back Holder LCD Unit LCD Hold Plate L LCD Plate R LCD Metal Damper Attaching the Inverter PCB and TS PCB TS PCBPCB Arranging the Cables View ESetting the LCD unit Setting the LCD Rear Cabinet, Hinge L and Hinge RSetting the Handle and Power SW PW LED PCB Arranging the SW LED PCBSW LED PCB Arranging the Power SW CableIO FPC LID SW Setting the IO PCBArrange the IO FPC IO FPCSetting the IO FPC IO PCBIO PCB LID SW TP PCB Setting the TP PCBAttaching the Cable Sheet, Insulation Sheet and the Sheet LED FFCArranging the HDD Main FPC Setting the HDD Main FPCNo4 Setting the LAN Cable and Modem Cable Main PCB LAN Cable Clamper Slot Setting the Main PCBView D View C Setting the RTC Battery Setting the PAD SW FFC Cover Setting the Wireless Module and SD PCB View CMini PCI Attaching the Memory Heat Plate Setting the SpeakerArranging the Dimm Cover and the Dimm Radiation Sheet Setting the Dimm Cover and Bottom CoverAttaching the Sheet to the MDC Modem Setting the KBD PCB, MDC Modem and LCD Cable/MIC FrameArranging the Cables and setting the LCD Cable/MIC Frame Arranging the Keyboard Setting the KB Cable Cover, Keyboard and Pcmcia ProtectorHinge Cover L No2 C No10 B No3 C No11 No4 No7 No5 Attaching the Sheet Setting the HDDSetting the Battery Pack, the HDD Pack and the FDD Pack Exploded View 19 ± 0.02 N.m 441 + 0.049 N.m 19 + 0.02 N.m 2.0 + 0.2 kgf.cm 45 + 0.05 N.m Screw tightening torque 19 + 0.02 N.m Screw tightening torque Description QTY Wireless LAN ModuleDFJS865ZA Power SW Cable Battery Pack DFJS954ZA Modem CablePower SW ARM Power SW AssyDFUQ0099ZA Power SW Spring Power SW KnobDFMD1161ZA PC Latch Angle DFHR3497YA Power SW SheetPC Latch Assy PC Latch LeverDFHP7162ZA HD FPC Tape DFMX1006ZA Cable SheetDFGT1055ZA Bottom Cover Sheet a DFHG370ZA Foot RubberDFHR3713ZA Mini PCI Spacer U2 DFHM0304YB MDC SpacerDFHM0330YB CN Spacer DRHM5118ZA ScrewDFMD7A49ZA Connector Ring DFHR3747ZA Power SW PWB CushionDFHR3743YA Power LED Packing Sheet DFHR3778ZA Battery Angle Sheet WDFHR8296ZB LS DAMPER, UNDER-2 DFHR5440YA GUIDE, FDD ConnectorDFHR4050ZA TUBE, LED DFHR8295ZC LS DAMPER, UNDER-1QTY RTC BatteryEEFCD0D151ER Page Page Page Page Page EEFCX0D331R EEFCX0D221R EEFCD0D101ERECJ2FF1A106Z EEFUD0J151EREEFUE0J181ER EEFCX0J101REEFCD0G101ER DCUI1C106HDBConnector ThermistorDiode FUSE, 2A IC, USB Power ControlDED10QS04TL Diode FUSE, 5AIC, Security Chip IC, Audio AMPIC, Gate Logic IC, EepromInductor ETQP4LR56WFC InductorInductor DDB5Z031J-L Inductor DDB5Z021C-YDETA144EETL Transistor Transistor B1GKCFJN0004 ERJ2RKF39R2X ERJ2GEJ681XERJ2RKF27R4X ERJ2RKF54R9XERJ2RKF1000X ERJ2GEJ562XERJ2GEJ750X ERJ2RKF2210XERJ2GEJ103X RESISTOR, 1/16W ERJ2RKF80R6X RESISTOR, 1/16WERJ2GEJ101X ERJ2GEJ222XERJ2RKF2550X ERJ2RKF1500XERJ2RKF1501X ERJ2GEJ390XERJ2GEJ120X ERJ2GEJ102X RESISTOR, 1/16W, 1KΩResistor Array ERJ2GEJ1R0X RESISTOR, 1/16W, 1ΩERJ2RKF22R6X DEARA8AJ103M Resistor ArrayERJ2GEJ472X ERJ6GEYJ680V ERJ2GEJ203X RESISTOR, 1/16W, 20KΩERJ2GEJ106X RESISTOR, 1/16W, 10MΩ ERJ2GEJ105X RESISTOR, 1/16W, 1MΩERJ2RKF3010X ERJ2RKD154XDEARA8CJ330M Resistor Array ERJ2GEJ100XERJ2GEJ683X RESISTOR, 1/16W, 68KΩ ERJ2GEJ363X RESISTOR, 1/16W, 36KΩERJ2GEJ333X RESISTOR, 1/16W, 33KΩ ERJ2GEJ223X RESISTOR, 1/16W, 22KΩERJ2RKF7501X ERJ2RKF5602X RESISTOR, 1/16W, 56KΩERJ2RKF1600X ERJ2RKF2150XERA3EEB1692V ERJ2RHD3652XERJ2GEJ154X ERA3EKB1623VDDB5Z021G-Y Inductor DDB5Z024E-L InductorPoly SW B1GKCFJN0004 Transistor ERJ3GEYJ102V RESISTOR, 1/16W, 1KΩLED IC, Flat PAD ControllerLED EVQPLDA15 ERJ2GEJ224XERJ2GEJ822X Resistor Array EVQPLDA15