Matsushita CF-29N3LGZBM manual Attaching the Inverter PCB and TS PCB, Ts Pcb

Page 33

■Attaching the Inverter PCB and TS PCB

1.Attach the Inverter PCB to the LCD Back Holder of the LCD Unit and connect the two Cables to the two Connectors on the Inverter PCB.

2.Attach the TS PCB to the LCD Back Holder of the LCD Unit and connect the two Cables to the two Connectors on TS PCB.

Safety Working

Connector

Terminal side is up.

TS PCB

Connectors

 

LCD Cable

0~2mm

 

 

Tape

Tape

Connectors

 

 

 

View "B"

View "C"

 

LCD Plate R

 

LCD Back Holder

Shape the Lamp Cable straighten

so that the Lamp Cable is not covered on the LCD Plate R or the LCD Back Damper Ass'y.

LCD Back

Damper Ass'y

View "A"

 

Tape

Inverter PCB

LCD Inverter

LCD Cable Tape

Case Spacer L

LCD Conductive

View "D"

Sheet

 

 

 

 

 

 

View "A"

Inverter

 

 

LCD Inverter

PCB

 

 

Case Spacer L

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Lamp Cable

View "B"

LCD Plate R

Connector

 

0~2mm

 

Tape

View "C"

Cable is up on

Lamp Cable

0~5mm

Lamp

Cable

View "D"

LCD Conductive Sheet or LCD Cable Tape

Cables

7-15

Page 32 Page 34
Image 33
Page 32 Page 34
Contents CF-29 For U.K This apparatus must be earthed for your safety How to replace the fuseLaser Safety Information Page Page Contents Basic Procedure Diagnosis ProcedureFlow Chart TroubleshootingError Diagnosis by Checking Beep Signal Sound Table of errors classified by beep soundsOutline of Post Stuck key 02F4 Eisa Cmos not writable Preparation EquipmentSelf Diagnosis Test Speaker Test Vesa Mode TestCPU A20 Gate Test Cache ON/OFF TestLAN Test Modem Test Wireless LAN Test CD TestTest Selection Error Messages and Troubleshooting Wiring Connection Diagram Removing the HDD Removing the Battery Pack, HDD Pack and FDD PackHDD FPC HDDRemove the KB Cable Cover, Keyboard and Pcmcia Protector Removing the Dimm Cover and Bottom Cover Removing the KBD PCB, MDC Modem and LCD Cable/MIC FrameRemoving the Speaker Removing the Wireless ModulePAD SW FFC Remove the HDD Main FPC Removing the TP PCBRemoving the IO PCB Removing the Handle and Power Removing LCD Unit Removing LCD Rear Cabinet, Hinge Hinge R Removing the Antenna PCB L Removing the Inverter PCB, TS PCB and LCD UnitArranging the Antenna L and R Cables Setting the Antenna PCB L and RView a Setting the Inverter PCB, TS PCB and LCD UnitAttaching the Touch Screen Panel TS FPC Arranging the Inverter PCB View B2Arranging the LCD Back Holder LCD Unit LCD Hold Plate L LCD Plate R LCD Metal Damper Attaching the Inverter PCB and TS PCB TS PCBPCB Arranging the Cables View ESetting the LCD unit Setting the LCD Rear Cabinet, Hinge L and Hinge RSetting the Handle and Power SW PW LED PCB Arranging the SW LED PCBSW LED PCB Arranging the Power SW CableArrange the IO FPC Setting the IO PCBIO FPC IO FPC LID SWSetting the IO FPC IO PCBIO PCB LID SW Attaching the Cable Sheet, Insulation Sheet and the Sheet Setting the TP PCBLED FFC TP PCBArranging the HDD Main FPC Setting the HDD Main FPCNo4 Setting the LAN Cable and Modem Cable Main PCB LAN Cable Clamper Slot Setting the Main PCBView D View C Setting the RTC Battery Setting the PAD SW FFC Cover Setting the Wireless Module and SD PCB View CMini PCI Attaching the Memory Heat Plate Setting the SpeakerArranging the Dimm Cover and the Dimm Radiation Sheet Setting the Dimm Cover and Bottom CoverAttaching the Sheet to the MDC Modem Setting the KBD PCB, MDC Modem and LCD Cable/MIC FrameArranging the Cables and setting the LCD Cable/MIC Frame Arranging the Keyboard Setting the KB Cable Cover, Keyboard and Pcmcia ProtectorHinge Cover L No2 C No10 B No3 C No11 No4 No7 No5 Attaching the Sheet Setting the HDDSetting the Battery Pack, the HDD Pack and the FDD Pack Exploded View 19 ± 0.02 N.m 441 + 0.049 N.m 19 + 0.02 N.m 2.0 + 0.2 kgf.cm 45 + 0.05 N.m Screw tightening torque 19 + 0.02 N.m Screw tightening torque DFJS865ZA Power SW Cable Wireless LAN ModuleBattery Pack DFJS954ZA Modem Cable Description QTYDFUQ0099ZA Power SW Spring Power SW AssyPower SW Knob Power SW ARMPC Latch Assy DFHR3497YA Power SW SheetPC Latch Lever DFMD1161ZA PC Latch AngleDFGT1055ZA Bottom Cover Sheet a DFMX1006ZA Cable SheetDFHG370ZA Foot Rubber DFHP7162ZA HD FPC TapeDFHM0330YB CN Spacer DFHM0304YB MDC SpacerDRHM5118ZA Screw DFHR3713ZA Mini PCI Spacer U2DFHR3743YA Power LED Packing Sheet DFHR3747ZA Power SW PWB CushionDFHR3778ZA Battery Angle Sheet W DFMD7A49ZA Connector RingDFHR4050ZA TUBE, LED DFHR5440YA GUIDE, FDD ConnectorDFHR8295ZC LS DAMPER, UNDER-1 DFHR8296ZB LS DAMPER, UNDER-2QTY RTC BatteryEEFCD0D151ER Page Page Page Page Page EEFCX0D331R EEFCX0D221R EEFCD0D101ERECJ2FF1A106Z EEFUD0J151EREEFCD0G101ER EEFCX0J101RDCUI1C106HDB EEFUE0J181ERConnector ThermistorDiode DED10QS04TL Diode IC, USB Power ControlFUSE, 5A FUSE, 2AIC, Gate Logic IC, Audio AMPIC, Eeprom IC, Security ChipInductor DDB5Z031J-L InductorInductor DDB5Z021C-Y Inductor ETQP4LR56WFCDETA144EETL Transistor Transistor B1GKCFJN0004 ERJ2RKF27R4X ERJ2GEJ681XERJ2RKF54R9X ERJ2RKF39R2XERJ2GEJ750X ERJ2GEJ562XERJ2RKF2210X ERJ2RKF1000XERJ2GEJ103X RESISTOR, 1/16W ERJ2RKF80R6X RESISTOR, 1/16WERJ2GEJ101X ERJ2GEJ222XERJ2RKF1501X ERJ2RKF1500XERJ2GEJ390X ERJ2RKF2550XResistor Array ERJ2GEJ102X RESISTOR, 1/16W, 1KΩERJ2GEJ1R0X RESISTOR, 1/16W, 1Ω ERJ2GEJ120XERJ2RKF22R6X DEARA8AJ103M Resistor ArrayERJ2GEJ472X ERJ2GEJ106X RESISTOR, 1/16W, 10MΩ ERJ2GEJ203X RESISTOR, 1/16W, 20KΩERJ2GEJ105X RESISTOR, 1/16W, 1MΩ ERJ6GEYJ680VDEARA8CJ330M Resistor Array ERJ2RKD154XERJ2GEJ100X ERJ2RKF3010XERJ2GEJ333X RESISTOR, 1/16W, 33KΩ ERJ2GEJ363X RESISTOR, 1/16W, 36KΩERJ2GEJ223X RESISTOR, 1/16W, 22KΩ ERJ2GEJ683X RESISTOR, 1/16W, 68KΩERJ2RKF1600X ERJ2RKF5602X RESISTOR, 1/16W, 56KΩERJ2RKF2150X ERJ2RKF7501XERJ2GEJ154X ERJ2RHD3652XERA3EKB1623V ERA3EEB1692VDDB5Z021G-Y Inductor DDB5Z024E-L InductorPoly SW LED ERJ3GEYJ102V RESISTOR, 1/16W, 1KΩIC, Flat PAD Controller B1GKCFJN0004 TransistorERJ2GEJ822X ERJ2GEJ224XResistor Array EVQPLDA15 LED EVQPLDA15
Top Page Image Contents