Char-Broil 463230510 manual Turn assembly upside down

Page 19

5	•	Turn assembly upside down.
	•	Attach the two fixed casters to left leg and the two locking casters to right leg.
		Use the provided caster wrench to fully tighten casters.

Caster Wrench

Locking Caster

Fixed Caster

Right Side Panel

Left Side Panel

Image 19

Contents Date Purchased Estimated assembly time 35-40 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsPre-Heating Your Grill TemperatureFirst Time Use Lava Rock / BriquettesRotisserie Cooking Food SafetyDirect Cooking Indirect CookingUsda Recommended Safe Minimum Internal Temperatures Storing Your Grill Why Clean?General Cleaning Routine CareLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling Nipple has to be centered into the LP cylinder valve For your safetyUseDo not household cleaning agents. Damage to gas LP Cylinder Leak TestConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Flange Nut Qty AssemblyFlange nuts at rear 20x2-3/8 Machine Screw QtyMetal Tap ScrewsFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down 20x1/2 Screw Qty Right side panel removed for clarityScrew 20x1/220x1/2 Machine Screw 20x1/2 Screw Back Firebox7mm Fiber Washer Qty Sideburner Tube #8-32 wing nut5mm Flat Washer Qty Right Door Left Door 5mm Lock Washer Hinge Pin hole#10-24x1/2 Machine Screw Qty Left HandleBar Burner Warming Rack Leg Wire Pivot Wire Cooking Grate AA BatteryTank Retainer Screw Heat ShieldGrease Tray LP Cylinder Not includedEmergencies Possible Cause Prevention/Solution TroubleshootingProblem Possible Cause Prevention/Solution Problem Possible Cause Prevention/SolutionSection Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

Turn assembly upside down.